Skip to content
FaultCrate
日本語

This is an open preview: every record can be read without an account.

GMC Yukon XL 2000–2006

GMC Yukon XLModel years 2000–2006

Change vehicle →
Clear the search
Add conditions (optional: symptom, model year, system, warning display, trouble code, kind of record)

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:NoiseCorrosion or rustWarning lightLeakLoss of engine power, no acceleration

remedyHub AssemblyRemove

Record by record

11 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

How it is said to have ended

  • says it was fixed1
  • says it held for a while2
  • says it came back1
  • says it did not fix it1
  • result not stated8

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (11)

Known issuesUnwanted ABS activation at low speed (front wheel speed sensor mounting corrosion)2

  1. Owner complaint2000 GMC YUKON XL ・ 2005-06-29

    ABS sensor failure in front passenger wheel bearing assembly; ABS malfunction on dry roads

    1. 1Fault

      ABS WOULD GO OFF ON DRY ROADS JUST BEFORE VEHICLE STOPPED.

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    ABS WOULD GO OFF ON DRY ROADS JUST BEFORE VEHICLE STOPPED.
    Remedy
    WE HAD THE WHOLE WHEEL BEARING ASSEMBLY REPLACED BY A NON DEALER GARAGE TO THE TUNE OF $382.47.
    Outcome
    NOW ONE YEAR LATER THE PROBLEM IS BACK.

  2. Owner complaint2002 GMC YUKON XL ・ 2008-10-15

    Unwanted antilock brake activation when brake pedal is depressed

    1. 1Fault

      WHEN THE BRAKE PEDAL WAS DEPRESSED, THE CONTACT EXPERIENCED UNWANTED ANTILOCK BRAKE ACTIVATION.

    2. 2Finding the cause

      Not stated

    3. 3Correction

    Read the sentences of the record
    Fault
    WHEN THE BRAKE PEDAL WAS DEPRESSED, THE CONTACT EXPERIENCED UNWANTED ANTILOCK BRAKE ACTIVATION.
    Remedy
    THE DEALER REPLACED THE ANTILOCK SPEED SENSOR AND THE FRONT HUB ASSEMBLY AT THE COST OF $600.

Known issuesAftermarket part (not the vehicle as built): Federal-Mogul National / Carquest replacement wheel hub assembly retention nut - recall 07E-1061

  1. Recall2000–2006 GMC YUKON XL ・ —

    Wheel Hub Assembly Bearing Nut Loosening Recall

    1. 1Fault

      • The inboard retention nut that maintains the hub bearing assembly can loosen, resulting in an ABS light indication, noise, and/or wheel separation from the vehicle; wheel separation can result in a vehicle crash.

    2. 2Finding the cause

      Steps to confirm (in the document’s order)

      1. On 2x4 vehicles, raise the vehicle on an approved hoist first; the hub assembly is good if a yellow, green or blue paint mark is seen on the grease cap on the inboard side of the steering knuckle.
      2. If the paint mark is not present, remove the wheel and the brake rotor and clean rust from the hub assembly face to check for the date code stamping.
      3. Defective hub assemblies can be identified by the country of origin on the package together with a recalled date code, by the date code on the package, or by the date code on the hub assembly.
      4. If a round yellow sticker is present on the box label, the part is good.

    3. 3Correction

      Repair

      1. The hub assemblies were manufactured for aftermarket use; owners of these parts should have them removed and replaced as soon as possible.
      2. Federal-Mogul will replace the recalled hub assemblies free of charge.

      Parts

      • The recalled part numbers are 515020, 515021, 515025, 515053, 515054, 515059 and 515060.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：This is an equipment recall by Federal-Mogul of certain wheel hub assemblies sold as replacement parts only.
    • Applies to：The recalled hub assemblies were packaged and sold between January 23, 2006 and December 20, 2007 under the National and CARQUEST Premium (BGS/Blue) brands, in 7 base part numbers.
    • Parts：The recalled part numbers are 515020, 515021, 515025, 515053, 515054, 515059 and 515060.
    • Applies to：The application lists include GMC 1500 Yukon (2WD) and GMC 1500 Yukon XL (2WD), 2001-2006.
    • Applies to：ILJIN manufactured the recalled hub assemblies from December 27, 2005 to November 29, 2007.
    • Condition：The inboard retention nut that maintains the hub bearing assembly can loosen, resulting in an ABS light indication, noise, and/or wheel separation from the vehicle; wheel separation can result in a vehicle crash.
    • Confirm：On 2x4 vehicles, raise the vehicle on an approved hoist first; the hub assembly is good if a yellow, green or blue paint mark is seen on the grease cap on the inboard side of the steering knuckle.
    • Confirm：If the paint mark is not present, remove the wheel and the brake rotor and clean rust from the hub assembly face to check for the date code stamping.
    • Confirm：Defective hub assemblies can be identified by the country of origin on the package together with a recalled date code, by the date code on the package, or by the date code on the hub assembly.
    • Confirm：If a round yellow sticker is present on the box label, the part is good.
    • Repair：The hub assemblies were manufactured for aftermarket use; owners of these parts should have them removed and replaced as soon as possible.
    • Repair：Federal-Mogul will replace the recalled hub assemblies free of charge.
    Cause
    CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
    Remedy
    FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
    Consequence
    WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.

ELECTRONIC STABILITY CONTROL (ESC)2

  1. Owner complaint2004 GMC YUKON XL ・ 2020-07-02

    Left front wheel bearing/hub assembly failure after 6,046 miles

    1. 1Fault

      VEHICLE WAS ON AN INTERSTATE HIGHWAY AND TRAVELING AT 70 MPH (= 112.7 km/h), IN A STRAIGHT LINE WHEN THIS OCCURRED.

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    VEHICLE WAS ON AN INTERSTATE HIGHWAY AND TRAVELING AT 70 MPH (= 112.7 km/h), IN A STRAIGHT LINE WHEN THIS OCCURRED.

  2. Owner complaint2004 GMC YUKON XL 1500 ・ 2008-11-08

    Traction stability warning and acceleration loss in GMC Yukon XL Denali

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

FUEL/PROPULSION SYSTEM1

  1. Owner complaint2001 GMC YUKON XL 1500 ・ 2014-11-15

    Fuel pump failure recurring four times; hub bearing and gas leak issues

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    JUST THIS PAST FEBRUARY I HAD A GAS LEAK FROM THE LINE AND A WHOLE TANK OF GAS WAS ON MY GARAGE FLOOR.

POWER TRAIN1

  1. Owner complaint2000 GMC YUKON XL 1500 ・ 2009-11-28

    Loose right front hub bearing assembly with noise

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

SERVICE BRAKES, HYDRAULIC1

  1. Owner complaint2001 GMC YUKON XL ・ 2005-10-24

    ABS warning light and rubbing sound from front wheels after hub/sensor repair

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    WE ALSO BEGAN HEARING A RUBBING SOUND COMING FROM THE FRONT WHEELS WHEN DRIVING. (1 more)
    Inspection
    WHEN WE TOOK THE YUKON IN TO BOB SELLERS TO INVESTIGATE FURTHER, THEY DID A COMPUTER SCAN CHECK WITH THE CODES INDICATING "PUMP MOTOR CK OPEN" AND PUMP MOTOR K SHORTED." (1 more)

STEERING1

  1. Owner complaint2003 GMC YUKON XL 1500 ・ 2006-08-27

    Both front wheel bearings failed at 51,280 miles

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

SUSPENSION1

  1. Owner complaint2003 GMC YUKON XL DENALI ・ 2005-08-01

    Front wheel bearing grinding noise after highway drive

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    I HAD JUST GOTTEN OFF THE INTERSTATE FROM A 4 HOUR DRIVE AND HEARD A AWFUL GRINDING NOISE COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. (1 more)
    Remedy
    I HAD THE WHEEL BEARING ASSEMBLY REPLACED AT A $494.70 EXPENSE TO ME AND IT IS CURRENTLY DRIVING FINE.
    Inspection
    THE DEALERSHIP CALLED ME MONDAY MORNING AND SAID THAT THE FRONT WHEEL BEARING HAD GONE BAD.

TIRES1

  1. Owner complaint2003 GMC YUKON XL ・ 2011-05-28

    Loud noise from left front wheel at highway speeds

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

    Read the sentences of the record
    Fault
    THERE WAS A LOUD NOISE COMING FROM THE LEFT FRONT WHEEL - ONLY WHILE DRIVING AT HIGHWAY SPEEDS.
    Remedy
    THE DEALERSHIP REPLACED THE LEFT FRONT HUB AND BEARING FOR $550. *TR

3 owner complaints have no classified sentences yet, so their causes and repairs are not picked out. Their text is in the list of records.