Skip to content
FaultCrate
日本語

This is an open preview: every record can be read without an account.

GMC Yukon XL 2000–2006

GMC Yukon XLModel years 2000–2006

Change vehicle →
Clear the search
2 conditions added

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:Liftgate, rear glass or door lockLeakNoiseCorrosion or rustSeat or seat heaterVibration or shudderPower windowAir conditioning or heater

Record by record

13 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

How it is said to have ended

  • says it was fixed1
  • result not stated5

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (11)

Known issuesBrake pipe (brake line) corrosion and rupture4

  1. Owner complaint2005 GMC YUKON DENALI XL ・ 2015-04-11

    Brake pedal to floor - brake lines burst from rust

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Brake pipe (brake line) corrosion and rupture

      Confirm

      • In the joint inspections, scaling or flaking corrosion was taken as indicating the onset of metal loss and given the second lowest ranking (2); a leaking or previously repaired pipe was the lowest (1).

      Repair

      1. GM recommends replacing the entire set of pipes whenever any pipe leaks or is corroded enough to need replacement.
      2. On June 28, 2013 GM released 66 new part numbers for servicing brake pipes in 1999-2007 GMT800 pickups and utility vehicles.

      Caution

      • Analysis of repair records indicates that consumers often elect to repair only the failed circuit.
    Read the sentences of the record
    Cause
    THE BRAKE LINES WERE RUSTED SO BAD THAT THEY BUSTED, AND CAUSED THE BRAKE FLUID TO LEAK OUT.

  2. Owner complaint2004 GMC YUKON XL 1500 ・ 2012-07-08

    Brake hose pinhole leak due to heavy rust in engine compartment

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Brake pipe (brake line) corrosion and rupture

      Confirm

      • In the joint inspections, scaling or flaking corrosion was taken as indicating the onset of metal loss and given the second lowest ranking (2); a leaking or previously repaired pipe was the lowest (1).

      Repair

      1. GM recommends replacing the entire set of pipes whenever any pipe leaks or is corroded enough to need replacement.
      2. On June 28, 2013 GM released 66 new part numbers for servicing brake pipes in 1999-2007 GMT800 pickups and utility vehicles.

      Caution

      • Analysis of repair records indicates that consumers often elect to repair only the failed circuit.
    Read the sentences of the record
    Fault
    BRAKE PEDAL WENT TO THE FLOOR.
    Cause
    IT APPEARS THAT INFERIOR QUALITY METAL BRAKE LINES WERE USED THAT RUST EASILY.

  3. Owner complaint2002 GMC YUKON XL ・ 2014-03-11

    Multiple brake issues including pedal to floor condition

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

  4. Owner complaint2002 GMC YUKON XL DENALI ・ 2012-08-22

    Broken and leaking brake lines due to severe underbody corrosion

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

STRUCTURE3

  1. Owner complaint2001 GMC YUKON XL 1500 ・ 2009-06-02

    Roof leaks when raining

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE CONTACT STATED THAT THE ROOF OF THE VEHICLE LEAKS WHENEVER IT RAINS.
    Cause
    THE ROOF IS LEAKING FROM THE FACTORY MADE ROOF RACK BECAUSE IT IS CORRODED AND CREATED A HOLE.
    Consequence
    AS A RESULT, HIS FAMILY BECOMES ILL WHEN THE FAILURE OCCURS.

  2. Manufacturer communication2003–2004 GMC YUKON XL DENALI ・ 2004-06-09

    Water Leaking from Center Roof Console

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      WATER LEAKING FROM CENTER ROOF CONSOLE. *TT

    Read the sentences of the record
    Remedy
    WATER LEAKING FROM CENTER ROOF CONSOLE. *TT

  3. Owner complaint2003 GMC YUKON XL 1500 ・ 2008-04-18

    Water leaks in through the sunroof when it rains

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    WHEN IT RAINS WATER LEAKS IN THROUGH THE SUNROOF. *TR

VISIBILITY2

  1. Manufacturer communication2005–2006 GMC YUKON XL ・ 2021-04-19(2 earlier editions of this document folded here)

    Sunroof Operation Issues - Preliminary Information

    1. 1Fault

      • Intermittent sunroof operation, bind, noise, auto-reverse and/or water leaks.

    2. 2Finding the cause

      Possible causes

      • Dirt and debris collect on the sunroof seal or in the tracks, affecting operation, causing noise or plugging the water drainage system.

      Steps to confirm (in the document’s order)

      • Verify that the module drain holes are not plugged.

    3. 3Correction

      Repair

      1. Open the sunroof and remove any obstacles or loose debris.
      2. Wipe the sunroof seal and the roof sealing area with a clean cloth, mild soap and water.

      Caution

      • Do not remove grease from the sunroof.
      • Some replaced sunroof module assemblies returned to the warranty parts center were found to need only cleaning of these areas.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：All models, model years 2005 - 2021.
    • Condition：Intermittent sunroof operation, bind, noise, auto-reverse and/or water leaks.
    • Cause：Dirt and debris collect on the sunroof seal or in the tracks, affecting operation, causing noise or plugging the water drainage system.
    • Repair：Open the sunroof and remove any obstacles or loose debris.
    • Confirm：Verify that the module drain holes are not plugged.
    • Repair：Wipe the sunroof seal and the roof sealing area with a clean cloth, mild soap and water.
    • Caution：Do not remove grease from the sunroof.
    • Caution：Some replaced sunroof module assemblies returned to the warranty parts center were found to need only cleaning of these areas.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This Preliminary Information communication advises the technician the steps on diagnosing the concern. Customer's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.

  2. Manufacturer communication2003 GMC YUKON XL ・ 2003-11-24

    Water Leak from Center Roof Console Due to Misadjusted Sunroof Glass

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      FULL SIZE UTILITIES BUILT AT JANESVILLE, WI ARE SUSPECT TO WATER LEAKING FROM THE CENTER ROOF CONSOLE CAUSED BY A MIS-ADJUSTED SUNROOF GLASS. *TT

    Read the sentences of the record
    Remedy
    FULL SIZE UTILITIES BUILT AT JANESVILLE, WI ARE SUSPECT TO WATER LEAKING FROM THE CENTER ROOF CONSOLE CAUSED BY A MIS-ADJUSTED SUNROOF GLASS. *TT

ELECTRICAL SYSTEM1

  1. Manufacturer communication2005–2006 GMC YUKON XL 2500 ・ 2016-08-11

    Sunroof Operation Concerns Diagnostic Guidance

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS.

    Read the sentences of the record
    Remedy
    THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS.

EQUIPMENT1

  1. Manufacturer communication2005–2006 GMC YUKON XL 2500 ・ 2016-10-25

    Sunroof Operation Issues Diagnostic Communication

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS.

    Read the sentences of the record
    Remedy
    THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON DIAGNOSING THE CONCERN. VEHICLE'S SUNROOF OPERATION INTERMITTENT, BIND, NOISE, AUTO-REVERSE, AND/OR WATER LEAKS.

Showing 11 of the 13 you can open. Narrow the search to see the rest.

2 owner complaints have no classified sentences yet, so their causes and repairs are not picked out. Their text is in the list of records.