Skip to content
FaultCrate
日本語

This is an open preview: every record can be read without an account.

GMC Yukon XL 2000–2006

GMC Yukon XLModel years 2000–2006

Change vehicle →
Clear the search
Add conditions (optional: symptom, model year, system, warning display, trouble code, kind of record)

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:LeakDoes not startStalls or shuts offGauge or instrument faultSmoke or fireCorrosion or rustFuel smellAir conditioning or heater

causeFuel PumpRemove

Record by record

19 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

How it is said to have ended

  • says it was fixed1
  • says it did not fix it2
  • result not stated8

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (19)

Known issuesBrake pipe (brake line) corrosion and rupture1

  1. Owner complaint2002 GMC YUKON XL DENALI ・ 2012-08-22

    Broken and leaking brake lines due to severe underbody corrosion

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

Known issuesOut of fuel with the gauge reading above empty, cranks but no start, stall (replace the fuel sensor, not the sender module)1

  1. Owner complaint2003 GMC YUKON XL ・ 2005-06-29

    Engine dies or fails to start with 1/4 tank or more of fuel

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    2003 YUKON XL WOULD DIE LIKE IT WAS OUT OF GAS WHEN IT STILL HAD AT LEAST 1/4 TANK OR IT WOULD NOT START WHEN IT HAD AT LEAST 1/4 TANK OF GAS BUT IF YOU ADDED 1 - 5 GALLONS (= 3.79–18.9 L) OF GAS IT WOULD START.
    Outcome
    SEEMS TO BE FINE NOW.

Known issuesIntake manifold gasket leak (cold idle misfire, lean codes)1

  1. Owner complaint2002 GMC YUKON XL ・ 2006-03-02

    2002 Yukon XL running poorly in cold weather; hard start and no start; intake gaskets and fuel pump issues

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Intake manifold gasket leak (cold idle misfire, lean codes)

      Confirm

      • The seals may leak around the bottom side of the port, which makes the vacuum leak hard to detect.

      Repair

      1. Only the current teal green gaskets should be used; the old gaskets were orange.
      2. The intake bolts must be replaced and not reused.

      Caution

      • Do not measure the intake manifold across all four intake runner ports.
    Read the sentences of the record
    Fault
    ORIGINAL PROBLEM: MY 2002 YUKON XL WAS RUNNING POORLY WHEN THE WEATHER TURNED COLD - BELOW 30 DEGREES. (1 more)
    Cause
    BOTH PROBLEMS ARE BECAUSE THEY WERE DESIGNED FOR USE WITH ETHANOL OR UNLEADED GAS.
    Inspection
    PROBLEM DIAGNOSED AS FAULTY INTAKE GASKETS DUE TO IMPROPER DESIGN. (1 more)

FUEL SYSTEM, GASOLINE13

  1. Owner complaint2002 GMC YUKON XL ・ 2004-10-20

    Vehicle would not start

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    VEHICLE WOULD NOT START.
    Cause
    FUEL PUMP WAS DEFECTIVE.
    Remedy
    HAD FUEL PUMP REPLACED.

  2. Owner complaint2000 GMC YUKON XL ・ 2003-03-21

    Fuel pump hot wire melted insulation, fuse blowing

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    OVER THE PAST FEW MONTHS, I HAVE HAD A PROBLEM WITH THE VEHICLE CONTINUALLY BLOWING A FUSE (ECM B FUSE).
    Cause
    UPON MY OWN RESEARCH INTO THE CIRCUITRY, I DETERMINED THE LIKELY PROBLEM WAS THE FUEL PUMP.
    Remedy
    I REPLACED THE FUEL PUMP AND UPON REMOVING AND INSPECTING THE OLD COMPONENT, I DISCOVERED THE HOT WIRE (GRAY WIRE) WHICH OPERATES THE PUMP MOTOR HAD BEEN HOT ENOUGH TO MELT THE INSULATION OFF THE WIRE.

  3. Owner complaint2005 GMC YUKON XL 1500 ・ 2017-07-13

    Fuel pump movement cuts fuel return line; hard to start

    1. 1Fault

      THE VEHICLE WAS DIFFICULT TO START.

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE VEHICLE WAS DIFFICULT TO START.
    Cause
    *LD THE CONSUMER STATED THE MOVEMENT OF THE FUEL PUMP IN THE FUEL TANK CUT THE FUEL RETURN LINE.

  4. Owner complaint2000 GMC YUKON XL 2500 ・ 2007-11-30

    Fuel leak at main fuel tank access port after complete filling

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    FUEL LEAK AT THE MAIN FUEL TANK ACCESS PORT.
    Outcome
    NOW ON NOVEMBER 29, 2007 AFTER COMPLETELY FILLING THE LEAK IS BACK AGAIN, UP UNTIL THIS POINT THE REPAIR ALOUD COMPLETE FILLING. *TR

  5. Owner complaint2002 GMC YUKON XL ・ 2006-05-17

    Fuel pump failure with blown ECMB fuse; vehicle stalls after fuse replacement

    1. 1Fault

    2. 2Finding the cause

    3. 3CorrectionNot repaired

    Read the sentences of the record
    Remedy
    TRUCK IS STILL NOT FIXED. JB
    Inspection
    FUEL PRESSURE WAS FOUND AT 24 PSI (= 165.5 kPa). (1 more)

  6. Owner complaint2005 GMC YUKON XL ・ 2009-07-15

    Fuel pump fails to pump gasoline, preventing engine start

    1. 1Fault

      SINCE JUNE 26, 2009, THE FUEL PUMP FAILS TO PUMP GASOLINE, WHICH PREVENTS THE VEHICLE FROM STARTING.

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    SINCE JUNE 26, 2009, THE FUEL PUMP FAILS TO PUMP GASOLINE, WHICH PREVENTS THE VEHICLE FROM STARTING.

  7. Owner complaint2004 GMC YUKON XL ・ 2007-02-05

    Fuel pump failure, vehicle left stranded

    1. 1Fault

      FUEL PUMP WENT OUT ON VEHICLE LEFT ME STRANDED ORIGINAL OWNERSHIP PAPER WORK LEFT IN VEHICLE SHOWS PREVIOUS WORK HAS BEEN DONE. *JB

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    FUEL PUMP WENT OUT ON VEHICLE LEFT ME STRANDED ORIGINAL OWNERSHIP PAPER WORK LEFT IN VEHICLE SHOWS PREVIOUS WORK HAS BEEN DONE. *JB

  8. Owner complaint2001 GMC YUKON XL ・ 2006-08-09

    Fuel leak from under vehicle

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    DT*: THE CONTACT STATED A PUDDLE OF FUEL HAD LEAKED FROM UNDER THE VEHICLE.
    Inspection
    AN INDEPENDENT REPAIR SHOP DETERMINED THE LEAK CAME FROM THE FUEL PUMP.

  9. Owner complaint2004 GMC YUKON XL ・ 2006-05-05

    Vehicle stalls and won't start; fuel pump replaced three times without resolution

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

  10. Owner complaint2000 GMC YUKON XL ・ 2005-09-13

    Gas gauge completely quit working

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    OUR GAS GAUGE ON OUR 2000 GMC YUKON COMPLETELY QUIT WORKING.
    Inspection
    TOOK IT IN THINKING IT WAS AN ELECTRICAL PROBLEM AND FOUND OUT THE FUEL PUMP WAS BROKEN.

  11. Owner complaint2002 GMC YUKON XL ・ 2005-06-06

    Vehicle stalling, not starting or running properly due to fuel pump

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

  12. Owner complaint2001 GMC YUKON XL ・ 2005-05-20

    Leaking fuel pump and strong smell of gas inside car

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    LEAKING FUEL PUMP AND STRONG SMELL OF GAS INSIDE OF CAR

  13. Owner complaint2002 GMC YUKON XL ・ 2003-05-20

    Fuel leak in garage after filling gas tank on 2000 GMC Yukon XL

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    FUEL LEAK IN MY GARAGE AFTER FILLING GAS TANK.
    Inspection
    SERVICE FACILITY DIAGNOSED PROBLEM TO BE FAULTY PLUNGER IN FUEL PUMP.

ENGINE AND ENGINE COOLING1

  1. Owner complaint2003 GMC YUKON XL ・ 2006-10-12

    Vehicle stalls repeatedly and wheel locks during driving

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    HAD TRUCK FOR ONE WEEK, HAVING A GOOD TIME, AND THEN THE CAR STALLED ELEVEN TIMES ON ME. (1 more)

FUEL SYSTEM, OTHER1

  1. Owner complaint2003 GMC YUKON XL ・ 2005-12-15

    Fuel pump failures on GMC Yukon XL

    1. 1Fault

      Not stated

    2. 2Finding the cause

    3. 3Correction

      Not stated

FUEL/PROPULSION SYSTEM1

  1. Owner complaint2001 GMC YUKON XL 1500 ・ 2014-11-15

    Fuel pump failure recurring four times; hub bearing and gas leak issues

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    JUST THIS PAST FEBRUARY I HAD A GAS LEAK FROM THE LINE AND A WHOLE TANK OF GAS WAS ON MY GARAGE FLOOR.

4 owner complaints have no classified sentences yet, so their causes and repairs are not picked out. Their text is in the list of records.