Skip to content
FaultCrate
日本語

This is an open preview: every record can be read without an account.

GMC Yukon 2000–2006

GMC YukonModel years 2000–2006

Change vehicle →
Clear the search
1 conditions added

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:Warning lightMisfire or rough idleLoss of engine power, no accelerationStalls or shuts offCorrosion or rustLeakNoise

Record by record

9 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (7)

Known issuesDTCs P2108, P1516 and U0107 (do not replace the TAC module)1

  1. Manufacturer communication2006 GMC YUKON ・ 2007-01-25

    LR4, LY2, L33, LH6, LM7, L59, LC9, LMG, LY5, LS2, LQ9, LQ4, L76, LY6 Throttle Actuator Control Module Communication

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      LR4, LY2, L33, LH6, LM7, L59, LC9, LMG, LY5, LS2, LQ9, LQ4, L76, LY6 THROTTLE ACTUATOR CONTROL (TAC). MODULE CODES, MIL/SES DTC'S P2108, P1516, U0107, REDUCED ENGINE POWER. *KB

      What the documents say to do

      DTCs P2108, P1516 and U0107 (do not replace the TAC module)

      Confirm

      • Perform the diagnostics for the DTCs, but delete the steps that involve replacing the TAC module.

      Caution

      • Do not replace the TAC module; the reference given is PIP 3812A.
    Read the sentences of the record
    Remedy
    LR4, LY2, L33, LH6, LM7, L59, LC9, LMG, LY5, LS2, LQ9, LQ4, L76, LY6 THROTTLE ACTUATOR CONTROL (TAC). MODULE CODES, MIL/SES DTC'S P2108, P1516, U0107, REDUCED ENGINE POWER. *KB

Known issuesIntake manifold gasket leak (cold idle misfire, lean codes)1

  1. Manufacturer communication2000–2006 GMC 5.3L L59 (E85 CAPABLE), AS WELL AS THE OTHER GEN 3 AND GEN 4 ENGINES (YUKON) ・ 2005-05-01

    P0300 from a leak at the upper manifold gasket: only the new teal green gasket 89017589 for repairs on the L59

    1. 1Fault

      • When a leak between the upper manifold and the gasket causes P0300 to set.

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Repair

      • Use only the 89017589 gasket (teal green) for repairs on the L59 engine, and do not replace the upper manifold unless it measures outside of the service manual specifications or is damaged.

      Parts

      • A new gasket made of FNK material (GM SPO p/n 89017589) has been released. The new gasket material is teal green; the original gaskets are orange.
      • The service kit containing the new gasket was released in October 2004. A small quantity of the old gasket kit, p/n 17113557, which contains two p/n 17122608 (orange) gaskets, remains in the system.
      • The 17113557 gasket (orange) can be used on the other engines. Once the 17113557 has been exhausted, only the 89017589 will be available for all engines.

      Part numbers printed in the document

      The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

      Caution

      • In that case, do not replace the entire upper manifold assembly, upper plenum and gaskets.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies specifically to the 5.3L L59 (E85 capable), as well as the other Gen 3 and Gen 4 engines.
    • Condition：When a leak between the upper manifold and the gasket causes P0300 to set.
    • Caution：In that case, do not replace the entire upper manifold assembly, upper plenum and gaskets.
    • Parts：A new gasket made of FNK material (GM SPO p/n 89017589) has been released. The new gasket material is teal green; the original gaskets are orange.
    • Parts：The service kit containing the new gasket was released in October 2004. A small quantity of the old gasket kit, p/n 17113557, which contains two p/n 17122608 (orange) gaskets, remains in the system.
    • Repair：Use only the 89017589 gasket (teal green) for repairs on the L59 engine, and do not replace the upper manifold unless it measures outside of the service manual specifications or is damaged.
    • Parts：The 17113557 gasket (orange) can be used on the other engines. Once the 17113557 has been exhausted, only the 89017589 will be available for all engines.

    Open this issue of GM TechLink ↗ The points above are read from an article of TechLink, GM’s monthly publication for dealership technicians. The article itself is not reproduced here.

    Remedy
    Upper Manifold Gasket Leak This information applies specifically to the 5.3L L59 (E85 capable), as well as the other Gen 3 and Gen 4 engines. If a leak between the upper manifold and gasket causes a DTC P0300 to set, do not replace the entire upper manifold assembly, upper plenum and gaskets. If a leak between the upper manifold and gasket causes a DTC P0300 to set, do not replace the entire upper manifold assembly, upper plenum and gaskets. A new gasket made of FNK material (GM SPO p/n 89017589) has been released. The new gasket material is teal green in color (fig. 7) ; the original gaskets are orange. The service kit containing the new gasket was released in October 2004. A small quantity of the old gasket kit, p/n 17113557, which contains two p/n 17122608 (orange) gaskets, remains in the system. Use only the 89017589 gasket (teal green) for repairs on the L59 engine, and do not replace the upper manifold unless it measures outside of the service manual specifications or is damaged. The 17113557 gasket (orange) can be used on the other engines. Once the 17113557 has been exhausted, only the 89017589 will be available for all engines.

Known issuesRear bank knock sensor corrosion from water intrusion (P0332)1

  1. Manufacturer communication2000–2002 GMC SPECIFIED VEHICLES 1998-2002 WITH 4.8L, 5.3L OR 6.0L ENGINE (YUKON) ・ 2002-09-01(also printed in 1 other issues)

    Audible spark knock, MIL illuminated, DTC P0332 set: replace the rear bank knock sensor (bulletin 02-06-04-023A)

    1. 1Fault

      • Audible spark knock (detonation), MIL illuminated, DTC P0332 set.

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Repair

      • Replace the rear bank knock sensor and RTV the area around the sensor.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Bulletin 02-06-04-023A, which replaces 02-06-04-023, lists "specified vehicles 1998-2002 with 4.8L, 5.3L or 6.0L Engine" (VINs V, T, Z, N, U; RPOs LR4, LM7, L59, LQ9, LQ4).
    • Condition：Audible spark knock (detonation), MIL illuminated, DTC P0332 set.
    • Repair：Replace the rear bank knock sensor and RTV the area around the sensor.

    Open this issue of GM TechLink ↗ The points above are read from an article of TechLink, GM’s monthly publication for dealership technicians. The article itself is not reproduced here.

    Remedy
    Bulletins – August 2002 02-06-04-023A; replaces 02-06-04-023; Audible Spark Knock (Detonation), MIL Illuminated, DTC P0332 Set (Replace Rear Bank Knock Sensor and RTV Area Around Sensor); specified vehicles 1998-2002 with 4.8L, 5.3L or 6.0L Engine (VINs V, T, Z, N, U – RPOs LR4, LM7, L59, LQ9, LQ4) Audible Spark Knock (Detonation), MIL Illuminated, DTC P0332 Set Replace Rear Bank Knock Sensor and RTV Area Around Sensor

ENGINE AND ENGINE COOLING2

  1. Manufacturer communication2004–2005 GMC YUKON ・ 2005-11-30

    LM7, L59 or L33 Engine Cold Start Issues and O2 Sensor Service

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Remedy
    LM7, L59 OR L33 ENGINES WITH COLD START ROUGH OR INCORRECT IDLE, MISFIRE, MALFUNCTION INDICATOR LAMP (MIL) OR FLASHING REQUIRING O2 SENSOR REPLACEMENT. *TT

  2. Manufacturer communication2002–2004 GMC YUKON ・ 2005-11-03

    Flexible Fuel (RPO L59) Rough Idle and Misfire Diagnostic

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      FLEXIBLE FUEL (RPO L59) ROUGH IDLE, MISFIRE, MALFUNCTION INDICATOR LAMP DIAGNOSTIC TROUBLE CODE P0300. *TT

    Read the sentences of the record
    Remedy
    FLEXIBLE FUEL (RPO L59) ROUGH IDLE, MISFIRE, MALFUNCTION INDICATOR LAMP DIAGNOSTIC TROUBLE CODE P0300. *TT

No component category1

  1. Manufacturer communication2002–2005 GMC FULL-SIZE PICKUPS AND UTILITIES (YUKON) ・ 2005-06-01

    Which vehicles may use E-85 fuel

    1. 1Fault

    2. 2Finding the cause

      Possible causes

      • Fuel containing more than 10% ethanol in vehicles not designated for E-85 can cause driveability issues, Service Engine Soon lights and increased fuel system corrosion.

    3. 3Correction

      Caution

      • All other gasoline engines, including all 5.3L V8 with VIN designators other than the letter Z, are not E-85 compatible.
      • Only vehicles designated for use with E-85 should use E-85 blended fuel.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：The only E-85 compatible vehicles GM produced are 2000 - 02 S series pickups with the 2.2L L43 engine and 2002 - 05 full-size pickups and utilities with the 5.3L L59 VIN code Z V8 engine.
    • Caution：All other gasoline engines, including all 5.3L V8 with VIN designators other than the letter Z, are not E-85 compatible.
    • Caution：Only vehicles designated for use with E-85 should use E-85 blended fuel.
    • Cause：Fuel containing more than 10% ethanol in vehicles not designated for E-85 can cause driveability issues, Service Engine Soon lights and increased fuel system corrosion.

    Open this issue of GM TechLink ↗ The points above are read from an article of TechLink, GM’s monthly publication for dealership technicians. The article itself is not reproduced here.

    Remedy
    E-85 Fuel The only E-85 compatible vehicles produced by General Motors are 2000 - 02 S series pickups equipped with the 2.2L L43 4-cylinder engine and 2002 - 05 full-size pickups and utilities equipped with the 5.3L L59 VIN code Z V8 engine. All other gasoline engines including all 5.3L V8 with VIN designators other than the letter Z are not E-85 compatible. Only vehicles designated for use with E-85 should use E-85 blended fuel. Use of fuel containing greater than 10% ethanol in non E-85 designated vehicles can cause driveability issues, Service Engine Soon lights, and increased fuel system corrosion.

FUEL SYSTEM, GASOLINE1

  1. Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2018-05-21(1 earlier editions of this document folded here)

    E85 Fuel Effects on Non-E85 Vehicles Information

    1. 1Fault

      • Using this fuel in a non-compatible vehicle may cause lean driveability concerns such as hesitation, sag and/or possible stalling.
      • Fuel trim DTC P0171 and/or P0174 may set.
      • Misfire DTC P0300 may set.
      • A Traction Control, Stability System or ABS lamp may illuminate, or a message may display in the DIC (if equipped).
      • Harsh and/or firm transmission shifts may occur because the transmission defaults to maximum line pressure.

    2. 2Finding the cause

      Steps to confirm (in the document’s order)

      1. Alcohol content is checked using Special Tool J-44175-A Fuel Composition Tester or CH-44175-A Fuel Composition Tester.
      2. General Motors started putting yellow gas caps on E85 Flex Fuel Vehicles (FFVs) as of Model Year 2006.

    3. 3Correction

      Repair

      • If the ethanol content exceeds the Owner Manual maximum of 10% or 15%, drain the fuel and refill the vehicle with gasoline, preferably a Top Tier brand.

      Caution

      • All Model Year 2011 and older non-FFV gasoline vehicles are designed to run on fuel containing no more than 10% ethanol.
      • Diesel engines are not E85 compatible.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：The list of compatible flexible-fuel vehicles includes 2002–2005 fullsize pickups and utilities with 5.3L, RPO L59.
    • Applies to：The list of compatible flexible-fuel vehicles includes 2006 Sierra, Yukon and Yukon XL with 5.3L, RPO L59.
    • Caution：All Model Year 2011 and older non-FFV gasoline vehicles are designed to run on fuel containing no more than 10% ethanol.
    • Caution：Diesel engines are not E85 compatible.
    • Condition：Using this fuel in a non-compatible vehicle may cause lean driveability concerns such as hesitation, sag and/or possible stalling.
    • Condition：Fuel trim DTC P0171 and/or P0174 may set.
    • Condition：Misfire DTC P0300 may set.
    • Condition：A Traction Control, Stability System or ABS lamp may illuminate, or a message may display in the DIC (if equipped).
    • Condition：Harsh and/or firm transmission shifts may occur because the transmission defaults to maximum line pressure.
    • Confirm：Alcohol content is checked using Special Tool J-44175-A Fuel Composition Tester or CH-44175-A Fuel Composition Tester.
    • Repair：If the ethanol content exceeds the Owner Manual maximum of 10% or 15%, drain the fuel and refill the vehicle with gasoline, preferably a Top Tier brand.
    • Confirm：General Motors started putting yellow gas caps on E85 Flex Fuel Vehicles (FFVs) as of Model Year 2006.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.

Showing 7 of the 9 you can open. Narrow the search to see the rest.