Skip to content
FaultCrate
日本語

This is an open preview: every record can be read without an account.

GMC Yukon 2000–2006

GMC YukonModel years 2000–2006

Change vehicle →
Clear the search
2 conditions added

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:Warning lightNoiseLeakGauge or instrument faultMisfire or rough idleVibration or shudderCorrosion or rustAir conditioning or heater

Record by record

11 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (9)

Known issuesIntermittent stall, misfire or crank no start (Ignition 1 feed wire broken near C148/C149)2

  1. Manufacturer communication2005–2006 GMC YUKON ・ 2006-10-01

    Intermittent stall, misfire or crank no start: Ignition 1 feed wire broken near C148/C149

    1. 1Fault

      • The engine may intermittently stall, misfire, or crank without starting, and there may be no trouble codes set.

    2. 2Finding the cause

      Possible causes

      • The pink Ignition 1 power feed wire may break inside the insulation near connector C148/C149.

      Steps to confirm (in the document’s order)

      1. Complete the SI diagnostics first; if they are inconclusive and the concern can be duplicated, inspect for a loss of Ignition 1 voltage to the ignition coils.
      2. Wiggle test the ignition coil harnesses to see if the concern can be duplicated.
      3. Inspect splices S160 and S159 for loose connections, and connectors C148 and C149 for wires breaking near the connector.

    3. 3Correction

      Broken Ignition Wire This information applies to the 2005-06 Chevrolet Express, Silverado, Suburban, Tahoe, GMC Savana, Sierra, Yukon equipped with a 4.8, 5.3 or 6.0 engine. The engine may intermittently stall, misfire, or crank without starting. There may be no trouble codes set. Complete the SI diagnostics for any symptoms or trouble codes found. If diagnostics are inconclusive, and an intermittent stall, misfire, or a crank no start can be duplicated, inspect for a loss of Ignition 1 voltage to the ignition coils. Wiggle test the ignition coil harnesses to see if the concern can be duplicated. Inspect splices S160 and S159 for loose connections. Also inspect connectors C148 and C149 for wires breaking near the connector. The pink Ignition 1 power feed wire may break inside the insulation near connector C148/C149.

      What the documents say to do

      Intermittent stall, misfire or crank no start (Ignition 1 feed wire broken near C148/C149)

      Confirm

      • Complete the SI diagnostics first; if they are inconclusive and the concern can be duplicated, inspect for a loss of Ignition 1 voltage to the ignition coils.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：The information applies to 2005-06 Chevrolet Express, Silverado, Suburban, Tahoe, GMC Savana, Sierra and Yukon equipped with a 4.8, 5.3 or 6.0 engine.
    • Condition：The engine may intermittently stall, misfire, or crank without starting, and there may be no trouble codes set.
    • Confirm：Complete the SI diagnostics first; if they are inconclusive and the concern can be duplicated, inspect for a loss of Ignition 1 voltage to the ignition coils.
    • Confirm：Wiggle test the ignition coil harnesses to see if the concern can be duplicated.
    • Confirm：Inspect splices S160 and S159 for loose connections, and connectors C148 and C149 for wires breaking near the connector.
    • Cause：The pink Ignition 1 power feed wire may break inside the insulation near connector C148/C149.

    Open this issue of GM TechLink ↗ The points above are read from an article of TechLink, GM’s monthly publication for dealership technicians. The article itself is not reproduced here.

    Remedy
    Broken Ignition Wire This information applies to the 2005-06 Chevrolet Express, Silverado, Suburban, Tahoe, GMC Savana, Sierra, Yukon equipped with a 4.8, 5.3 or 6.0 engine. The engine may intermittently stall, misfire, or crank without starting. There may be no trouble codes set. Complete the SI diagnostics for any symptoms or trouble codes found. If diagnostics are inconclusive, and an intermittent stall, misfire, or a crank no start can be duplicated, inspect for a loss of Ignition 1 voltage to the ignition coils. Wiggle test the ignition coil harnesses to see if the concern can be duplicated. Inspect splices S160 and S159 for loose connections. Also inspect connectors C148 and C149 for wires breaking near the connector. The pink Ignition 1 power feed wire may break inside the insulation near connector C148/C149.

  2. Manufacturer communication2005–2006 GMC YUKON ・ 2006-09-28

    Loss of Ignition 1 Voltage to the Ignition Coils

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      LOSS OF IGNITION 1 VOLTAGE TO THE IGNITION COILS. CONSUMER EXPERIENCED INTERMITTENT STALL, MISFIRE, OR CRANK NO START. THERE MAY BE NO TROUBLE CODES SET. *KB UPDATED 3/17/09. *PE

      What the documents say to do

      Intermittent stall, misfire or crank no start (Ignition 1 feed wire broken near C148/C149)

      Confirm

      • Complete the SI diagnostics first; if they are inconclusive and the concern can be duplicated, inspect for a loss of Ignition 1 voltage to the ignition coils.
    Read the sentences of the record
    Remedy
    LOSS OF IGNITION 1 VOLTAGE TO THE IGNITION COILS. CONSUMER EXPERIENCED INTERMITTENT STALL, MISFIRE, OR CRANK NO START. THERE MAY BE NO TROUBLE CODES SET. *KB UPDATED 3/17/09. *PE

Known issuesOut of fuel with the gauge reading above empty, cranks but no start, stall (replace the fuel sensor, not the sender module)1

  1. Manufacturer communication2001–2005 GMC FULL SIZE PICKUPS AND UTILITIES (YUKON) ・ 2005-12-01

    Cranks but no start, stall, or inaccurate fuel gauge with the tank out of fuel: replace the fuel sensor

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Repair

      • Replace the fuel sensor.

      Caution

      • Do not replace the fuel sender module; the reference is bulletin 04-08-49-018E.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Row for 2001-2005 Full Size Pickups and Utilities: cranks but no start, stall, inaccurate/incorrect fuel gauge reading, no fuel, vehicle is out of fuel and the fuel gauge reads above empty.
    • Repair：Replace the fuel sensor.
    • Caution：Do not replace the fuel sender module; the reference is bulletin 04-08-49-018E.

    Open this issue of GM TechLink ↗ The points above are read from an article of TechLink, GM’s monthly publication for dealership technicians. The article itself is not reproduced here.

    Remedy
    Truck Issues — Fix It Right the First Time (new issues in bold) 2001-2005 Full Size Pickups and Utilities – Cranks But No Start, Stall, Inaccurate/Incorrect Fuel Gauge Reading, No Fuel, Vehicle is Out of Fuel and Fuel Gauge Reads Above Empty Replace fuel sensor. Don’t replace fuel sender module. 04-08-49-018E

Known issuesEngine fuel rail crossover tube retainer screws may break (5.3L RPO L59) - recall 04V-3761

  1. Recall2005 GMC YUKON ・ 2004-08-05

    Fuel Rail Crossover Tube Retainer Screws Recall

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Engine fuel rail crossover tube retainer screws may break (5.3L RPO L59) - recall 04V-376

      Confirm

      • Check for leaks: ignition ON with the engine OFF for 2 seconds, ignition OFF for 10 seconds, ignition ON with the engine OFF, then visually inspect for fuel leaks.

      Repair

      1. Dealers inspect the fuel rail crossover tube and replace the retainer screws if necessary.
      2. Hold the fuel crossover tube retainer to the bracket on the fuel rail with locking pliers, using enough force to keep the retainer from moving without damaging any parts.

      Caution

      • The GM bulletin lists Tahoe and Yukon models because Canadian vehicles are included in the bulletin.
    Read the sentences of the record
    Cause
    On certain vehicles, the fuel rail crossover tube retainer screws were not manufactured to specifications and may break. If a tube retainer screw breaks, fuel could leak from the fuel rail crossover joint, the engine may stall and, if an ignition source were present, an engine compartment fire could occur. Correction: Dealers will inspect the fuel rail crossover tube assembly and, if necessary, replace the two tube retainer screws.

ENGINE AND ENGINE COOLING2

  1. Manufacturer communication2005 GMC YUKON ・ 2005-10-29

    Intermittent Stall, Low Power, and Hard Restart in High Heat and High Altitude

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      INTERMITTENT STALL, LOW POWER, AND HARD RESTART WHEN THE VEHICLE IS USED DURING HIGH AMBIENT TEMPERATURES AND IN HIGH ALTITUDES. *TT

    Read the sentences of the record
    Remedy
    INTERMITTENT STALL, LOW POWER, AND HARD RESTART WHEN THE VEHICLE IS USED DURING HIGH AMBIENT TEMPERATURES AND IN HIGH ALTITUDES. *TT

  2. Manufacturer communication2003–2005 GMC YUKON ・ 2004-12-17

    Crank No Start, Stall, Hard Start, and No Cranking RPM

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      CRANK NO START, STALL, HARD START, AND NO CRANKING RPM. *EH

    Read the sentences of the record
    Remedy
    CRANK NO START, STALL, HARD START, AND NO CRANKING RPM. *EH

EQUIPMENT2

  1. Manufacturer communication2000–2006 GMC YUKON ・ 2022-04-05

    Fuel Injector Maintenance Cleaning Service Bulletin

    1. 1Fault

      • Use the detergent fuel additives when the vehicle shows loss of power, diminished performance, frequent stalls or no starts, or a noted decrease in fuel economy.

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Repair

      1. The only preventative maintenance GM endorses for gasoline engine fuel systems is GM Fuel System Treatment PLUS added to a tank of fuel at each oil change.
      2. Regular use of a TOP TIER Detergent Gasoline helps prevent the build-up of intake valve and fuel injector deposits.

      Parts

      • Part number 88865595 (88865598 for Canada): CLEANER, FUEL SYSTEM TREATMENT 12 OZ. (GASOLINE).
      • Part number 88865596 (88865599 for Canada): CLEANER, FUEL SYSTEM TREATMENT 12 OZ. (FLEX FUEL).

      Part numbers printed in the document

      The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

      Caution

      • GM does not endorse, support or acknowledge the need for fuel injector cleaning as a preventative maintenance procedure.
      • Fuel injector cleaning is approved only when a published GM driveability or DTC diagnostic service procedure directs it.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2022 and earlier GM passenger cars and trucks.
    • Caution：GM does not endorse, support or acknowledge the need for fuel injector cleaning as a preventative maintenance procedure.
    • Caution：Fuel injector cleaning is approved only when a published GM driveability or DTC diagnostic service procedure directs it.
    • Repair：The only preventative maintenance GM endorses for gasoline engine fuel systems is GM Fuel System Treatment PLUS added to a tank of fuel at each oil change.
    • Repair：Regular use of a TOP TIER Detergent Gasoline helps prevent the build-up of intake valve and fuel injector deposits.
    • Condition：Use the detergent fuel additives when the vehicle shows loss of power, diminished performance, frequent stalls or no starts, or a noted decrease in fuel economy.
    • Parts：Part number 88865595 (88865598 for Canada): CLEANER, FUEL SYSTEM TREATMENT 12 OZ. (GASOLINE).
    • Parts：Part number 88865596 (88865599 for Canada): CLEANER, FUEL SYSTEM TREATMENT 12 OZ. (FLEX FUEL).

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This service bulletin provides information for maintenance cleaning of the fuel injectors and gasoline detergent additive.

  2. Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2021-04-19(1 earlier editions of this document folded here)

    Winter Fuel Grade Use in Warm Months 2020 – Drivability Issues

    1. 1Fault

      • In rare instances customers may complain of a fuel smell, longer starts, hesitation and, in extreme cases, engine stalls.
      • Any combination of DTCs P0300, P0171, P0174 and P228C may be set.

    2. 2Finding the cause

      Possible causes

      • Using winter fuel in summer weather may cause drivability concerns.

      Steps to confirm (in the document’s order)

      • The concern should not be a single event but multiple occurrences associated with hot days.

    3. 3Correction

      Caution

      • No repair is required; the vehicles are not damaged and will recover.
      • There is no other remedy until summer fuel and/or cooler weather is available.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to all brands and models with gasoline engines, model years 2000 - 2022.
    • Applies to：The involved region is North America.
    • Condition：In rare instances customers may complain of a fuel smell, longer starts, hesitation and, in extreme cases, engine stalls.
    • Condition：Any combination of DTCs P0300, P0171, P0174 and P228C may be set.
    • Cause：Using winter fuel in summer weather may cause drivability concerns.
    • Confirm：The concern should not be a single event but multiple occurrences associated with hot days.
    • Caution：No repair is required; the vehicles are not damaged and will recover.
    • Caution：There is no other remedy until summer fuel and/or cooler weather is available.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in driving and fuel use.  Due to the surplus of winter grade fuel sitting in storage (pipelines/stations) the EPA is waiving the fuel vapor requirement.  This will extend the use of winter fuel into the summer months. The drivability concerns should not be single events but should be multiple occurrences associated with hot days.

FUEL SYSTEM, GASOLINE1

  1. Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2018-05-21(1 earlier editions of this document folded here)

    E85 Fuel Effects on Non-E85 Vehicles Information

    1. 1Fault

      • Using this fuel in a non-compatible vehicle may cause lean driveability concerns such as hesitation, sag and/or possible stalling.
      • Fuel trim DTC P0171 and/or P0174 may set.
      • Misfire DTC P0300 may set.
      • A Traction Control, Stability System or ABS lamp may illuminate, or a message may display in the DIC (if equipped).
      • Harsh and/or firm transmission shifts may occur because the transmission defaults to maximum line pressure.

    2. 2Finding the cause

      Steps to confirm (in the document’s order)

      1. Alcohol content is checked using Special Tool J-44175-A Fuel Composition Tester or CH-44175-A Fuel Composition Tester.
      2. General Motors started putting yellow gas caps on E85 Flex Fuel Vehicles (FFVs) as of Model Year 2006.

    3. 3Correction

      Repair

      • If the ethanol content exceeds the Owner Manual maximum of 10% or 15%, drain the fuel and refill the vehicle with gasoline, preferably a Top Tier brand.

      Caution

      • All Model Year 2011 and older non-FFV gasoline vehicles are designed to run on fuel containing no more than 10% ethanol.
      • Diesel engines are not E85 compatible.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：The list of compatible flexible-fuel vehicles includes 2002–2005 fullsize pickups and utilities with 5.3L, RPO L59.
    • Applies to：The list of compatible flexible-fuel vehicles includes 2006 Sierra, Yukon and Yukon XL with 5.3L, RPO L59.
    • Caution：All Model Year 2011 and older non-FFV gasoline vehicles are designed to run on fuel containing no more than 10% ethanol.
    • Caution：Diesel engines are not E85 compatible.
    • Condition：Using this fuel in a non-compatible vehicle may cause lean driveability concerns such as hesitation, sag and/or possible stalling.
    • Condition：Fuel trim DTC P0171 and/or P0174 may set.
    • Condition：Misfire DTC P0300 may set.
    • Condition：A Traction Control, Stability System or ABS lamp may illuminate, or a message may display in the DIC (if equipped).
    • Condition：Harsh and/or firm transmission shifts may occur because the transmission defaults to maximum line pressure.
    • Confirm：Alcohol content is checked using Special Tool J-44175-A Fuel Composition Tester or CH-44175-A Fuel Composition Tester.
    • Repair：If the ethanol content exceeds the Owner Manual maximum of 10% or 15%, drain the fuel and refill the vehicle with gasoline, preferably a Top Tier brand.
    • Confirm：General Motors started putting yellow gas caps on E85 Flex Fuel Vehicles (FFVs) as of Model Year 2006.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.

Showing 9 of the 11 you can open. Narrow the search to see the rest.