Skip to content
FaultCrate
日本語

This is an open preview: every record can be read without an account.

GMC Yukon 2000–2006

GMC YukonModel years 2000–2006

Change vehicle →
Clear the search
1 conditions added

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:Reduced brakingCorrosion or rustLeakABS activates (at low speed and the like)

issueBrake pipe (brake line) corrosion and ruptureRemove

Record by record

10 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

How it is said to have ended

  • result not stated4

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (10)

Known issuesBrake pipe (brake line) corrosion and rupture10

  1. Owner complaint2000 GMC YUKON ・ 2014-01-23

    Brake failure and ABS activation while driving, brake line corroded

    1. 1Fault

    2. 2Finding the cause

    3. 3CorrectionNot repaired

    Read the sentences of the record
    Fault
    THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH (= 8.05 km/h), THE BRAKES FAILED TO ENGAGE WHEN DEPRESSED AND THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOOR BOARD. (1 more)
    Remedy
    THE VEHICLE WAS NOT REPAIRED. (1 more)
    Inspection
    THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DISCOVERED THAT THE BRAKE LINE WAS CORRODED.

  2. Owner complaint2000 GMC YUKON ・ 2013-08-16

    Brake line rupture during braking; ruptured again in 2013

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    DRIVING ON SOUTH ON ROUTE 95 THROUGH CONNECTICUT AT APPROXIMATELY 65 MPH (= 104.6 km/h) ON 17AUG12. (1 more)
    Remedy
    DEALER REPLACED 40" OF BRAKE LINE.
    Inspection
    THEY FOUND THE LEFT REAR BRAKE LINE HAD RUPTURED DUE TO RUST.
    Consequence
    NARROWLY AVOIDED REAR ENDING CAR IN FRONT OF ME AT HIGH SPEED. (1 more)

  3. Owner complaint2000 GMC YUKON ・ 2011-09-24

    Brake pedal loss, no brakes due to corroded and ruptured brake lines

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    AFTER NO WARNING (LIGHTS, CHIMES OR ALARMS), APPLIED BRAKES AND PEDAL WENT TO THE FLOOR. NO BRAKES. (1 more)
    Cause
    EVERYONE KNOWS WHEN YOU PLACE DIFFERENT METALS IN CONTACT WHERE THEY CAN GET WET, YOU WILL GET ELECTRO-CHEMICAL CORROSION OF THE WEAKER METAL, IN THIS CASE, ALUMINUM. (1 more)
    Inspection
    *TR LOCAL DEALER SAYS ALUMINUM BRAKE LINES WERE SEVERELY CORRODED AND HAD RUPTURED.
    Consequence
    LUCKILY IT WAS VERY EARLY AND NOBODY WAS ON THE ROAD WHEN I BLEW THROUGH A STOP SIGN INTERSECTION.

  4. Owner complaint2000 GMC YUKON ・ 2014-07-10

    Brake line burst during braking, vehicle rolled into intersection

    1. 1Fault

      Not stated

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Remedy
    TO REMEDY SITUATION I REPLACED ALL BRAKE LINES. *TR
    Inspection
    FURTHER INVESTIGATION FOUND BRAKE LINE BURST.

  5. Owner complaint2000 GMC YUKON ・ 2014-03-03

    Brake fluid leak and soft brake pedal

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      I PUT IN A HALF A BOTTLE OF BRAKE FLUID INTO THE RESERVOIR.

      What the documents say to do

      Brake pipe (brake line) corrosion and rupture

      Confirm

      • In the joint inspections, scaling or flaking corrosion was taken as indicating the onset of metal loss and given the second lowest ranking (2); a leaking or previously repaired pipe was the lowest (1).

      Repair

      1. GM recommends replacing the entire set of pipes whenever any pipe leaks or is corroded enough to need replacement.
      2. On June 28, 2013 GM released 66 new part numbers for servicing brake pipes in 1999-2007 GMT800 pickups and utility vehicles.

      Caution

      • Analysis of repair records indicates that consumers often elect to repair only the failed circuit.
    Read the sentences of the record
    Fault
    I WAS DRIVING AROUND TOWN WHEN THE BRAKES FELT A LITTLE SOFT. (3 more)
    Remedy
    I PUT IN A HALF A BOTTLE OF BRAKE FLUID INTO THE RESERVOIR.
    Inspection
    TOOK VEHICLE TO SHOP AND WAS TOLD THAT THE BRAKE LINES ALL NEEDED TO BE REPLACED. *TR

  6. Owner complaint2000 GMC YUKON ・ 2013-05-10

    Brake failure and stuck pedal while driving 30-40 MPH

    1. 1Fault

    2. 2Finding the cause

    3. 3CorrectionNot repaired

      THE VEHICLE WAS NOT REPAIRED.

      What the documents say to do

      Brake pipe (brake line) corrosion and rupture

      Confirm

      • In the joint inspections, scaling or flaking corrosion was taken as indicating the onset of metal loss and given the second lowest ranking (2); a leaking or previously repaired pipe was the lowest (1).

      Repair

      1. GM recommends replacing the entire set of pipes whenever any pipe leaks or is corroded enough to need replacement.
      2. On June 28, 2013 GM released 66 new part numbers for servicing brake pipes in 1999-2007 GMT800 pickups and utility vehicles.

      Caution

      • Analysis of repair records indicates that consumers often elect to repair only the failed circuit.
    Read the sentences of the record
    Fault
    THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30-40 MPH (= 48.3–64.4 km/h), THE BRAKES FAILED TO ENGAGE WHEN DEPRESSED. (1 more)
    Remedy
    THE VEHICLE WAS NOT REPAIRED.
    Inspection
    THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE BRAKE LINE WAS CORRODED, CAUSING BRAKE FLUID TO LEAK FROM THE VEHICLE.

  7. Owner complaint2000 GMC YUKON ・ 2012-03-12

    Total brake failure

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Brake pipe (brake line) corrosion and rupture

      Confirm

      • In the joint inspections, scaling or flaking corrosion was taken as indicating the onset of metal loss and given the second lowest ranking (2); a leaking or previously repaired pipe was the lowest (1).

      Repair

      1. GM recommends replacing the entire set of pipes whenever any pipe leaks or is corroded enough to need replacement.
      2. On June 28, 2013 GM released 66 new part numbers for servicing brake pipes in 1999-2007 GMT800 pickups and utility vehicles.

      Caution

      • Analysis of repair records indicates that consumers often elect to repair only the failed circuit.
    Read the sentences of the record
    Fault
    MY GMC YUKON EXPERIENCED TOTAL BRAKE FAILURE.
    Consequence
    MY WIFE WAS DRIVING WITH OUR 3 MONTH OLD SON AND LUCKILY SHE WAS ABLE TO STOP OFF OF THE SIDE OF THE ROAD IN A FIELD.

  8. Owner complaint2000 GMC YUKON ・ 2013-04-21

    Brake pedal went to the floor while backing up to hitch trailer

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Brake pipe (brake line) corrosion and rupture

      Confirm

      • In the joint inspections, scaling or flaking corrosion was taken as indicating the onset of metal loss and given the second lowest ranking (2); a leaking or previously repaired pipe was the lowest (1).

      Repair

      1. GM recommends replacing the entire set of pipes whenever any pipe leaks or is corroded enough to need replacement.
      2. On June 28, 2013 GM released 66 new part numbers for servicing brake pipes in 1999-2007 GMT800 pickups and utility vehicles.

      Caution

      • Analysis of repair records indicates that consumers often elect to repair only the failed circuit.
    Read the sentences of the record
    Fault
    I WAS JUST BACKING UP TO HITCH A TRAILER WHEN THE BRAKE PEDAL WENT TO THE FLOOR, THANKFULY IT HAPPENED BEFORE I HOOKED THE TRAILER AS I WOULD CERTAINLY HAVE HAD AN ACCIDENT TOWING A TRAILER WITH NO BRAKES!

  9. Owner complaint2000 GMC YUKON ・ 2012-10-09

    Brake line corrosion failure from ABS module to rear brakes

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Brake pipe (brake line) corrosion and rupture

      Confirm

      • In the joint inspections, scaling or flaking corrosion was taken as indicating the onset of metal loss and given the second lowest ranking (2); a leaking or previously repaired pipe was the lowest (1).

      Repair

      1. GM recommends replacing the entire set of pipes whenever any pipe leaks or is corroded enough to need replacement.
      2. On June 28, 2013 GM released 66 new part numbers for servicing brake pipes in 1999-2007 GMT800 pickups and utility vehicles.

      Caution

      • Analysis of repair records indicates that consumers often elect to repair only the failed circuit.

  10. Owner complaint2000 GMC YUKON ・ 2005-09-09

    Total brake failure at low speed due to rusted brake lines

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Brake pipe (brake line) corrosion and rupture

      Confirm

      • In the joint inspections, scaling or flaking corrosion was taken as indicating the onset of metal loss and given the second lowest ranking (2); a leaking or previously repaired pipe was the lowest (1).

      Repair

      1. GM recommends replacing the entire set of pipes whenever any pipe leaks or is corroded enough to need replacement.
      2. On June 28, 2013 GM released 66 new part numbers for servicing brake pipes in 1999-2007 GMT800 pickups and utility vehicles.

      Caution

      • Analysis of repair records indicates that consumers often elect to repair only the failed circuit.
    Read the sentences of the record
    Fault
    THE CONSUMER EXPERIENCED TOTAL BRAKE FAILURE AT A LOW SPEED ON A BUSY INTERSECTION. (2 more)
    Inspection
    THE DEALERSHIP LATER FOUND THAT THE STAINLESS BRAKE LINES RUSTED THROUGH.

1 owner complaints have no classified sentences yet, so their causes and repairs are not picked out. Their text is in the list of records.