Skip to content
FaultCrate
日本語

This is an open preview: every record can be read without an account.

GMC Yukon 2000–2006

GMC YukonModel years 2000–2006

Change vehicle →
Clear the search
2 conditions added

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:Gauge or instrument faultWarning lightAir conditioning or heaterLights (headlights, turn signals)NoiseLoss of engine power, no accelerationSmoke or fireLeak

Record by record

13 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

How it is said to have ended

  • says it came back1

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (13)

Known issuesHVAC blower motor resistor module / connector overheating2

  1. Owner complaint2005 GMC YUKON ・ 2011-07-29

    Interior vehicle fire in dash

    1. 1Fault

    2. 2Finding the cause

      APPEARS SERVICE BULLETINS WERE ISSUED ABOUT REPLACING OVER HEATING RESISTORS FOR THE (HAVC) OPERATING SYSTEM.

    3. 3Correction

      Not stated

      What the documents say to do

      HVAC blower motor resistor module / connector overheating

      Repair

      1. Dealers install a new blower motor resistor and resistor module connector.
      2. Cut the wires back far enough to remove any melted insulation.

      Caution

      • The connector must be replaced even if it was replaced in an earlier repair.
    Read the sentences of the record
    Fault
    INTERIOR VEHICLE FIRE IN DASH. (1 more)
    Cause
    APPEARS SERVICE BULLETINS WERE ISSUED ABOUT REPLACING OVER HEATING RESISTORS FOR THE (HAVC) OPERATING SYSTEM.
    Consequence
    VEHICLE IS NOW TOTALLED.

  2. Owner complaint2004 GMC YUKON ・ 2016-08-22

    Blower resistor module corrosion from water entry into HVAC system

    1. 1Fault

    2. 2Finding the cause

    3. 3CorrectionNot repaired

      THE VEHICLE WAS NOT REPAIRED.

      What the documents say to do

      HVAC blower motor resistor module / connector overheating

      Repair

      1. Dealers install a new blower motor resistor and resistor module connector.
      2. Cut the wires back far enough to remove any melted insulation.

      Caution

      • The connector must be replaced even if it was replaced in an earlier repair.
    Read the sentences of the record
    Remedy
    THE VEHICLE WAS NOT REPAIRED.

Known issuesPositive battery cable contact with steering shaft universal joint (Denali) - Transport Canada 20010921

  1. Recall2001 GMC YUKON ・ 2001-04-12

    Positive battery cable fire risk recall

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Positive battery cable contact with steering shaft universal joint (Denali) - Transport Canada 2001092

      Repair

      1. Dealers inspect the cable routing and reroute if necessary.
      2. The cable is also inspected for wear and replaced if necessary.
    Read the sentences of the record
    Cause
    On certain Yukon Denali and Yukon XL Denali vehicles, the positive battery cable assembly that could come in contact with the steering shaft universal joint. This could eventually cause a wear through of the cable assembly convoluted conduit and cable insulation and result in intermittent electrical shorting. This could result in overheating and igniting of the cable insulation and conduit and a possible underhood fire. Correction: Dealers will inspect the positive battery cable for proper routing and reroute if necessary. Cable will also be inspected for wear of the conduit and cable insulation, and replaced if necessary.

Known issuesRear seat audio and/or rear HVAC controls inoperative (replace the RSA, not the console)1

  1. Owner complaint2004 GMC YUKON ・ 2011-05-10

    Rear seat radio inoperative and console overheating, passenger headlight bulb failures

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    THE CONTACT STATED THAT THE REAR SEAT RADIO FUNCTION WAS NOT FUNCTIONING. (2 more)
    Remedy
    ALSO, THE CONTACT STATED THAT THE PASSENGER SIDE DAYTIME RUNNING HEADLIGHT BULB WAS REPLACED THREE DIFFERENT TIMES. (1 more)

ELECTRICAL SYSTEM9

  1. Owner complaint2004 GMC YUKON DENALI ・ 2011-04-01

    Rear driver's side bucket seat caught fire

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    REAR BUCKET SEAT (DRIVER'S SIDE) CAUGHT FIRE.
    Cause
    THUS, CAR SEAT HEATER SOME HOW TURNED ITSELF ON, REMAINED ON, OVERHEATED, AND CAUGHT SEAT CUSHION MATERIAL ON FIRE.
    Consequence
    FURTHER, FIRE WAS DISCOVERED BEFORE SPREADING, ENGULFING CAR AND ENDANGERING OTHERS IN THE BUSY SCHOOL PARKING LOT.

  2. Owner complaint2006 GMC YUKON DENALI ・ 2018-09-05

    Passenger side under-dash area caught fire while driving

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE PASSENGER SIDE UNDER DASH BORED CAUGHT ON FIRE. (1 more)
    Cause
    I BELIEVE IT WAS THE MOTER BLOWER THAT SET ON FIRE DUE TO THATS WERE FIRE CAME FROM .AS WELL WHEN I LOOKED UNDER THE HOOD THERE WAS NOTHING WRONG WITH IT STILL PERFECT CONDITION.

  3. Owner complaint2005 GMC YUKON ・ 2015-06-16

    Smoke from air conditioner vents and cable fire under dashboard while driving

    1. 1Fault

    2. 2Finding the cause

    3. 3CorrectionNot repaired

      THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED.

    Read the sentences of the record
    Fault
    WHILE DRIVING AT APPROXIMATELY 55 MPH (= 88.5 km/h), THE CONTACT NOTICED SMOKE COMING FROM THE AIR CONDITIONER VENTS. (1 more)
    Remedy
    THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED.

  4. Owner complaint2004 GMC YUKON DENALI ・ 2014-08-28

    Dashboard fire with smoke from center console and battery compartment

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    AT APPROXIMATELY 1:54 PM I WAS LEAVING WORK AND I DIDN'T GET ABOUT 1,000 FEET (= 304.8 m) WHEN I BEGAN TO SEE SMOKE COMING FROM THE CENTER CONSOLE AREA WHERE THE CIGARETTE LIGHTER WAS. (3 more)
    Consequence
    I SUSTAINED SMOKE INHALATION AND HEAT BURNS ON MY FACE. (1 more)

  5. Owner complaint2004 GMC YUKON DENALI ・ 2011-11-08

    Vehicle caught fire while parked in driveway

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    MY HUSBAND'S 2004 YUKON DENALI CAUGHT FIRE WHILE PARKED IN THE DRIVEWAY OF HOME. (1 more)
    Consequence
    FORTUNATELY, NO ONE WAS INJURED, BUT IT IS UNKNOWN WHY THE VEHICLE IGNITED AND WAS ON FIRE.

  6. Owner complaint2002 GMC YUKON ・ 2003-01-30

    Multiple electrical systems failure after liquid spill in rear cup holder

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    TO GO OUT ON THE FRONT DASH PANEL IN ADDITION TO MAKING SOMETHINGS COME ON WHEN THEY WERE IN THE OFF POSITION. (1 more)
    Cause
    I ASSUMED THAT MAYBE A FUSE HAD WENT OUT.

  7. Owner complaint2003 GMC YUKON DENALI ・ 2015-06-08

    Major electrical issues with lights, horn, and warning light

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    TRUCK STARTED TO HAVE MAJOR ELETRICAL ISSUES. (6 more)

  8. Owner complaint2000 GMC YUKON ・ 2002-03-29

    Battery positive terminal cracked and pulled out, acid leak

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    BATTERY POSITIVE TERMINAL CRACKED AND PULLED OUT OF BATTERY CAUSING ACID TO LEAK AND COULD HAVE CAUSED A FIRE.

  9. Owner complaint2002 GMC YUKON ・ 2002-02-06

    Smoke and flames from engine compartment

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    SMOKE FROM ENGINE COMPARTMENT, THEN NOTICED FLAMES COMING FROM ENGINE COMPARTMENT, DUE TO ELECTRICAL LOCKS FAILED AND CAR TOTAL LOSS