Skip to content
FaultCrate
日本語

This is an open preview: every record can be read without an account.

GMC Yukon 2000–2006

GMC YukonModel years 2000–2006

Change vehicle →
Clear the search
1 conditions added

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:Liftgate, rear glass or door lockNoiseAir conditioning or heaterSeat or seat heaterPower windowLeakVibration or shudderCorrosion or rust

Record by record

257 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

How it is said to have ended

  • says it held for a while1
  • says it came back3
  • says it did not fix it5
  • result not stated25

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (26)

Known issuesLoose or missing rear wheelhouse plugs (exhaust gas entry) - recall 00V-3432

  1. Recall2000–2001 GMC YUKON ・ —

    Rear Wheelhouse Plug Recall

    1. 1Fault

      Not stated

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Cause
    VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.
    Remedy
    DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.
    Consequence
    THESE GASES COULD FLOW INTO THE PASSENGER COMPARTMENT IF THE PLUG IS MISSING OR LOOSE AND COULD CAUSE POSSIBLE ILLNESS, UNCONSCIOUSNESS, OR DEATH.

  2. Recall2000–2001 GMC YUKON ・ 2000-11-17

    Rear wheelhouse plug inspection and replacement recall

    1. 1Fault

      Not stated

    2. 2Finding the cause

    3. 3Correction

      Not stated

      What the documents say to do

      Loose or missing rear wheelhouse plugs (exhaust gas entry) - recall 00V-343

      Repair

      • Dealers inspect for loose or missing wheelhouse plugs and install new plugs if necessary.
    Read the sentences of the record
    Cause
    Certain vehicles may have loose or missing rear wheelhouse plugs. Under certain operating conditions, exhaust gases can flow forward and accumulate in the rear wheelhouse. These exhaust gases could flow into the passenger compartment if the wheelhouse plug is missing or loose and may cause possible illness, unconsciousness or death. Correction: Dealers will inspect for loose or missing wheelhouse plugs, and install new plugs if necessary.

Known issuesHeadliner sagging (hook and loop patch detached; reattach with epoxy)1

  1. Manufacturer communication2003–2006 GMC YUKON ・ 2018-12-17

    Headliner Sagging - Velcro Reattachment Preliminary Information

    1. 1Fault

      • The headliner sags or does not stay tight to the roof or around the sunroof opening, if equipped.

    2. 2Finding the cause

      Steps to confirm (in the document’s order)

      • On visual inspection, the hook and loop patch adhered to the roof, headliner or sunroof may be found detached.

    3. 3Correction

      Repair

      • Reattach the hook and loop patch using Hardman Double Bubble Epoxy part number 04001 or equivalent.

      Parts

      • Part 04001, Double Bubble Epoxy, quantity 1, to be obtained locally.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：The model list names GMC Yukon, 2003 - 2019.
    • Condition：The headliner sags or does not stay tight to the roof or around the sunroof opening, if equipped.
    • Confirm：On visual inspection, the hook and loop patch adhered to the roof, headliner or sunroof may be found detached.
    • Repair：Reattach the hook and loop patch using Hardman Double Bubble Epoxy part number 04001 or equivalent.
    • Parts：Part 04001, Double Bubble Epoxy, quantity 1, to be obtained locally.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This Preliminary Information communicates an issues with the headliner sagging and how to reattach the velcro using Hardman Double Bubble Epoxy part number 04001.

Known issuesRear door upper hinge welds out of specification (FMVSS 214) - recall 03V-0371

  1. Recall2003 GMC YUKON ・ 2003-06-02

    Side impact door hinge weld inspection recall

    1. 1Fault

      Not stated

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Cause
    CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.
    Remedy
    DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, OR GMC AT 1-800-462-8782.
    Consequence
    AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.

Known issuesRear HVAC ticking noise, no rear temperature or mode control, DTC B0434 / B3764 (revised auxiliary HVAC control module)1

  1. Owner complaint2003 GMC YUKON ・ 2008-12-02

    Rear heater not working

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

    Read the sentences of the record
    Fault
    REAR HEATER NOT WORKING. (1 more)
    Remedy
    ON JULY 25, 2006, THE DEALER REPLACED:" COMPRESSOR ASSEMBLY-REPLACE SENSOR, INSIDE AIR TEMPERATURE-REPLACE, CASE, AUXILIARY HEATER ONE PIECE-REPLACE" AT 38,371 MILES (= 61,752 km). (1 more)

Known issuesSecond-row rearward folding head restraint pinch points - recall 02V-2531

  1. Recall2000–2002 GMC YUKON ・ —

    Head restraint pinch point covers

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      DEALERS WILL INSTALL PROTECTIVE COVERS OVER THE PINCH POINTS. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR CADILLAC AT 1-800-458-8006.

      What the documents say to do

      Second-row rearward folding head restraint pinch points - recall 02V-253

      Repair

      • Dealers install protective covers over the pinch points.
    Read the sentences of the record
    Cause
    ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH REARWARD FOLDING HEAD RESTRAINTS ON THE SECOND ROW SEATS, TWO POTENTIAL PINCH POINTS EXIST ON EACH OF THE FOLDING HEAD RESTRAINTS WHEN THE RESTRAINTS ARE FOLDED REARWARD AS THE SEATBACK IS FOLDED DOWN.
    Remedy
    DEALERS WILL INSTALL PROTECTIVE COVERS OVER THE PINCH POINTS. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR CADILLAC AT 1-800-458-8006.
    Consequence
    IF A PERSON WERE TO INSERT THEIR FINGER(S) INTO THE PINCH POINT WHEN THE HEAD RESTRAINT FOLDS, IT COULD TRAP AND PINCH THE FINGER(S) CAUSING INJURY.

Known issuesConversion equipment (not the vehicle as built): Southern Comfort running board courtesy lights overheating - recall 03V-0941

  1. Recall2000–2003 GMC YUKON ・ 2003-07-03

    Running board courtesy lights overheat or fire risk recall

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Cause
    CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
    Remedy
    DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
    Consequence
    THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.

STRUCTURE6

  1. Owner complaint2006 GMC YUKON DENALI ・ 2018-07-15

    Rear liftgate glass flew off while driving; hinges defective

    1. 1Fault

      GLASS FLEW OFF WHILE DRIVING IN NORMAL CONDITIONS.

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    GLASS FLEW OFF WHILE DRIVING IN NORMAL CONDITIONS.
    Cause
    POOR DESIGN IS THE PROBLEM.
    Remedy
    SAFELITE AUTO (972.379-2704) REPLACED GLASS ON 6/16/18. (2 more)

  2. Owner complaint2005 GMC YUKON ・ 2013-07-28

    Spare tire security latch susceptible to rust, difficult to release

    1. 1Fault

      THIS PREVENTS IT FROM RELEASING THE SPARE TIRE FROM THE VEHICLE.

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THIS PREVENTS IT FROM RELEASING THE SPARE TIRE FROM THE VEHICLE.
    Cause
    THE PROBLEM IS THAT THE LATCH IS DESIGNED VERY POORLY AND QUITE SUSCEPTIBLE TO RUSTING FROM ROAD SALT.
    Consequence
    IT WOULD AT LEAST GREATLY EXTEND THE AMOUNT OF TIME PERSON WOULD BE WORKING ON THEIR VEHICLE ALONG THE ROAD. *TR

  3. Owner complaint2006 GMC YUKON DENALI ・ 2010-01-22

    Roof damaged by telephone pole impact while driving

    1. 1Fault

      Not stated

    2. 2Finding the cause

      Not stated

    3. 3CorrectionNot repaired

      THE CONTACT HAS BEEN WAITING FOR THE PARTS SINCE OCTOBER 26, 2009.

    Read the sentences of the record
    Remedy
    THE CONTACT HAS BEEN WAITING FOR THE PARTS SINCE OCTOBER 26, 2009.
    Consequence
    WHILE DRIVING APPROXIMATELY 35 MPH (= 56.3 km/h), THE CONTACT CRASHED INTO A TELEPHONE POLE, IT BROKE AND FELL ON THE ROOF OF THE VEHICLE.

  4. Manufacturer communication2000–2006 GMC YUKON ・ 2022-06-13(1 earlier editions of this document folded here)

    Unusual Noise Diagnosis Technical Assistance

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Repair

      • The noise can be recorded as audio or video with sound on a cell phone to send to TAC, or the PICOSCOPE can be used as a microphone.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：All brands and models, model years 2000 - 2022.
    • Repair：The noise can be recorded as audio or video with sound on a cell phone to send to TAC, or the PICOSCOPE can be used as a microphone.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.Â

  5. Owner complaint2004 GMC YUKON ・ 2019-12-05

    Subframe rusted and corroded at routine maintenance

    1. 1Fault

    2. 2Finding the cause

    3. 3CorrectionNot repaired

      THE VEHICLE WAS NOT REPAIRED.

    Read the sentences of the record
    Remedy
    THE VEHICLE WAS NOT REPAIRED.
    Inspection
    WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, IT WAS DISCOVERED THAT THE ENTIRE SUBFRAME OF THE VEHICLE WAS RUSTED AND CORRODED.

  6. Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2018-04-16

    TPO plastic fascias pre-painting/cleaning process

    1. 1Fault

      • All fascias except those of the Corvette, Camaro and Cadillac XLR are made of TPO.

    2. 2Finding the cause

      Steps to confirm (in the document’s order)

      • If unsure of the plastic type, look for the plastic symbol (TPO) on the back of the part.

    3. 3Correction

      Repair

      1. Wash with soap and water, then clean with a 50% mix of isopropyl alcohol and water (or a waterborne cleaner).
      2. Scuff sand as the paint supplier recommends, then reclean with the 50% mix of isopropyl alcohol and water (or a waterborne cleaner).

      Caution

      • A solvent-type cleaner will soften or begin to dissolve the primer; base coats do not affect this primer.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2013 and prior GM passenger cars and trucks.
    • Condition：All fascias except those of the Corvette, Camaro and Cadillac XLR are made of TPO.
    • Confirm：If unsure of the plastic type, look for the plastic symbol (TPO) on the back of the part.
    • Repair：Wash with soap and water, then clean with a 50% mix of isopropyl alcohol and water (or a waterborne cleaner).
    • Repair：Scuff sand as the paint supplier recommends, then reclean with the 50% mix of isopropyl alcohol and water (or a waterborne cleaner).
    • Caution：A solvent-type cleaner will soften or begin to dissolve the primer; base coats do not affect this primer.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This informational bulletin provides information pre-painting/cleaning process for TPO plastic fascias.

VISIBILITY5

  1. Owner complaint2000 GMC YUKON ・ 2002-01-23

    Horrible odor from ventilation system

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      THE DEALER IS GOING TO PUT A COATING OF CHEMICALS ON THE EVAPORATOR COILS THAT WILL (KILL?) (1 more)

    Read the sentences of the record
    Fault
    HORRIBLE ODOR EMITTED THRU VENTILATION SYSTEM. (2 more)
    Remedy
    THE DEALER IS GOING TO PUT A COATING OF CHEMICALS ON THE EVAPORATOR COILS THAT WILL (KILL?) (1 more)
    Consequence
    DON'T KNOW IF ASSOCIATED BUT MY FAMILY HAS BEEN ILL WITH ALOT OF RESPIRATORY PROBLEMS, WALKING PNEUMONIA (2OUT OF 4) IN SAME WEEK , AND MY 5YR OLD HAS BEEN PLAGUED BY VIOLENT VOMITING.

  2. Manufacturer communication2005–2006 GMC YUKON ・ 2022-07-25(4 earlier editions of this document folded here)

    Sunroof Operation Concerns – Diagnostic Information

    1. 1Fault

      • Customers may comment on intermittent sunroof operation, bind, noise, auto-reverse and/or water leaks.

    2. 2Finding the cause

      Possible causes

      • Dirt and debris may collect on the sunroof seal or in the tracks and affect operation, cause noise or plug the water drainage system.

    3. 3Correction

      Repair

      1. Open the sunroof, remove any obstacles or loose debris, and verify that the module drain holes are not plugged.
      2. Wipe the sunroof seal and roof sealing area with a clean cloth, mild soap and water; do not remove grease from the sunroof.

      Caution

      • Some replaced sunroof module assemblies were tested and found that simple cleaning of these areas would have repaired the condition without replacing the assembly.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：The model table lists all brands and models for model years 2005 - 2023.
    • Condition：Customers may comment on intermittent sunroof operation, bind, noise, auto-reverse and/or water leaks.
    • Cause：Dirt and debris may collect on the sunroof seal or in the tracks and affect operation, cause noise or plug the water drainage system.
    • Repair：Open the sunroof, remove any obstacles or loose debris, and verify that the module drain holes are not plugged.
    • Repair：Wipe the sunroof seal and roof sealing area with a clean cloth, mild soap and water; do not remove grease from the sunroof.
    • Caution：Some replaced sunroof module assemblies were tested and found that simple cleaning of these areas would have repaired the condition without replacing the assembly.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This Preliminary Information communication advises the technician the steps on diagnosing the concern. Customer's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.

  3. Manufacturer communication2005–2006 GMC YUKON DENALI ・ 2018-06-04(2 earlier editions of this document folded here)

    Outside Mirror Warranty Coverage Determination

    1. 1Fault

      • The document gives warranty submission guidelines for outside rearview mirrors; it contains no diagnosis or repair.

    2. 2Finding the cause

      Not stated

    3. 3Correction

      This warranty bulletin explains how to determine if an outside mirrior was damaged by the customer and what is considered warranty and non-warranty.

    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2018 and earlier GM passenger cars and light duty trucks.
    • Condition：The document gives warranty submission guidelines for outside rearview mirrors; it contains no diagnosis or repair.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This warranty bulletin explains how to determine if an outside mirrior was damaged by the customer and what is considered warranty and non-warranty.

  4. Manufacturer communication2005–2006 GMC YUKON DENALI ・ 2018-06-04

    Power Foldaway Mirror Glass Shake, Flutter Correction

    1. 1Fault

      • The outside power foldaway mirror glass shakes or flutters while driving at normal speeds.
      • The mirror(s) may also not stay in the unfolded position.

    2. 2Finding the cause

      Possible causes

      • The mirror was folded or unfolded by hand, or was obstructed while power folding.

    3. 3Correction

      Repair

      1. Full size trucks with power outside mirror RPOs DL3, DL8, DPN or DQS: cycle the mirrors through three complete power fold and unfold events to relearn the positions and reset the mechanisms.
      2. All other models: fold and unfold the mirrors one time with the mirror controls to relearn the positions and reset the power fold mechanisms.

      Caution

      • A popping noise during the reset is normal after a manual fold or unfold.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2005 through 2018 GM passenger cars and light duty trucks.
    • Condition：The outside power foldaway mirror glass shakes or flutters while driving at normal speeds.
    • Condition：The mirror(s) may also not stay in the unfolded position.
    • Cause：The mirror was folded or unfolded by hand, or was obstructed while power folding.
    • Repair：Full size trucks with power outside mirror RPOs DL3, DL8, DPN or DQS: cycle the mirrors through three complete power fold and unfold events to relearn the positions and reset the mechanisms.
    • Repair：All other models: fold and unfold the mirrors one time with the mirror controls to relearn the positions and reset the power fold mechanisms.
    • Caution：A popping noise during the reset is normal after a manual fold or unfold.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This Bulletin provides procedures to correct a condition of Power Foldaway Mirror Glass Shake, Flutter at Normal Driving Speeds

  5. Manufacturer communication2006 GMC YUKON DENALI ・ 2018-04-16

    Polarized Sunglasses and Windshield Glass Markings

    1. 1Fault

      • Spots show on the rear and side windows when the vehicle is in sunlight, and look stronger through polarized glasses or sunglasses.

    2. 2Finding the cause

      Possible causes

      • The spots are "quench marks", an unintentional side effect of the glass tempering process.

    3. 3Correction

      Caution

      • This is a normal condition of tempered glass; explain that to the customer.
      • The marks are not seen on front windshields or laminated side glass.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2014 and prior GM passenger cars and trucks.
    • Condition：Spots show on the rear and side windows when the vehicle is in sunlight, and look stronger through polarized glasses or sunglasses.
    • Cause：The spots are "quench marks", an unintentional side effect of the glass tempering process.
    • Caution：This is a normal condition of tempered glass; explain that to the customer.
    • Caution：The marks are not seen on front windshields or laminated side glass.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This preliminary bulletin explains the marks in the glass are normal when wearing polarized sunglasses and do not replace any glass for this reason.

ELECTRICAL SYSTEM2

  1. Owner complaint2004 GMC YUKON DENALI ・ 2011-04-01

    Rear driver's side bucket seat caught fire

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    REAR BUCKET SEAT (DRIVER'S SIDE) CAUGHT FIRE.
    Cause
    THUS, CAR SEAT HEATER SOME HOW TURNED ITSELF ON, REMAINED ON, OVERHEATED, AND CAUGHT SEAT CUSHION MATERIAL ON FIRE.
    Consequence
    FURTHER, FIRE WAS DISCOVERED BEFORE SPREADING, ENGULFING CAR AND ENDANGERING OTHERS IN THE BUSY SCHOOL PARKING LOT.

  2. Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2018-05-21

    Informational Bulletin on Latest PI and Service Bulletins

    1. 1Fault

      • The document is a field product reminder list of issues by vehicle line under the heading Fix it Right the First Time; it is an index to other documents.

    2. 2Finding the cause

      Not stated

    3. 3Correction

      This informational bulletin provides a list of newly released PI and Bulletins in regards to recent released vehicles so that vehicles can be fixed right the first time in for service.

    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2013 and earlier GM passenger cars and trucks.
    • Condition：The document is a field product reminder list of issues by vehicle line under the heading Fix it Right the First Time; it is an index to other documents.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This informational bulletin provides a list of newly released PI and Bulletins in regards to recent released vehicles so that vehicles can be fixed right the first time in for service.

EQUIPMENT2

  1. Manufacturer communication2002–2006 GMC YUKON DENALI ・ 2018-06-04

    Informational Bulletin Revision 05-08-48-001B

    1. 1Fault

      • The bulletin gives retail and wholesale service personnel guidelines for using the windshield replacement labor operation.

    2. 2Finding the cause

      Not stated

    3. 3Correction

      This informational bulletin provides a revision for 05-08-48-001B to add 2010-2014 model years and update Labor Operation.

    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2014 and prior GM passenger cars and light duty trucks.
    • Condition：The bulletin gives retail and wholesale service personnel guidelines for using the windshield replacement labor operation.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This informational bulletin provides a revision for 05-08-48-001B to add 2010-2014 model years and update Labor Operation.

  2. Manufacturer communication2001–2006 GMC YUKON DENALI ・ 2018-05-21(1 earlier editions of this document folded here)

    Liftgate Applique Replacement Procedure

    1. 1Fault

      • Condition 1: a dimpling or deformation is seen near an outer edge of the liftgate center applique.
      • Condition 2: paint damage on the liftgate at the lower outboard edges of the center applique.

    2. 2Finding the cause

      Possible causes

      • The applique design might allow deformation or dimpling of its surface if the retaining nuts are overtightened.
      • The applique design together with the forming of the license plate pocket in the liftgate may let the lower outboard edges of the applique contact the liftgate.

    3. 3Correction

      Repair

      1. For 2011 or earlier vehicles, replace the liftgate center applique with the appropriate new service part from the table.
      2. To create clearance, add GM washer P/N 15911310 to the applique between the foam washer and the mounting boss at each of the four mounting stud locations.

      Part numbers printed in the document

      The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

      Parts

      • P/N 15911310 is a 0.25 mm thick Mylar washer.
      • Applique 22777530 is for GMC non-hybrid without rear vision camera (-UVC).
      • Applique 22777531 is for GMC non-hybrid with rear vision camera (&UVC).

      Part numbers printed in the document

      The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

      Caution

      • The updated applique design went into production for the 2012 model year; the applique should not need replacement on a 2012 or newer vehicle unless Condition 1 is present.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2007-2013 GMC Yukon models and Yukon XL models (note: earlier Yukon model years are not listed).
    • Condition：Condition 1: a dimpling or deformation is seen near an outer edge of the liftgate center applique.
    • Cause：The applique design might allow deformation or dimpling of its surface if the retaining nuts are overtightened.
    • Condition：Condition 2: paint damage on the liftgate at the lower outboard edges of the center applique.
    • Cause：The applique design together with the forming of the license plate pocket in the liftgate may let the lower outboard edges of the applique contact the liftgate.
    • Repair：For 2011 or earlier vehicles, replace the liftgate center applique with the appropriate new service part from the table.
    • Caution：The updated applique design went into production for the 2012 model year; the applique should not need replacement on a 2012 or newer vehicle unless Condition 1 is present.
    • Repair：To create clearance, add GM washer P/N 15911310 to the applique between the foam washer and the mounting boss at each of the four mounting stud locations.
    • Parts：P/N 15911310 is a 0.25 mm thick Mylar washer.
    • Parts：Applique 22777530 is for GMC non-hybrid without rear vision camera (-UVC).
    • Parts：Applique 22777531 is for GMC non-hybrid with rear vision camera (&UVC).

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This preliminary information bulletin provides a procedure for replacement of the liftgate applique for concerns regarding the applique being deformed or dimpled or paint damage at the lower edge of the applique

EQUIPMENT ADAPTIVE/MOBILITY2

  1. Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2021-04-26

    Underbody Component Corrosion Guidance

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

    Read the sentences of the record
    Remedy
    Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

  2. Manufacturer communication2000–2006 GMC YUKON DENALI ・ 2021-04-26

    Underbody Component Corrosion Information

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

    Read the sentences of the record
    Remedy
    Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.

SEATS2

  1. Owner complaint2001 GMC YUKON ・ 2001-07-02

    Front passenger seat back wobbles when coming to a stop

    1. 1Fault

      BACK OF FRONT PASSENGER SEAT WOBBLES WHEN COMING TO A STOP.

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    BACK OF FRONT PASSENGER SEAT WOBBLES WHEN COMING TO A STOP.
    Remedy
    DEALER HAD REPLACED TRACKING.
    Outcome
    IT CORRECTED DEFECT FOR ONE MONTH. (1 more)

  2. Manufacturer communication2006 GMC YUKON DENALI ・ 2024-05-16(2 earlier editions of this document folded here)

    Interior Cleaning Products - Availability

    1. 1Fault

      • The document covers interior cleaning of the instrument panel, hard or plastic surfaces, seats, carpet, leather and vinyl, and the availability of cleaner, stain remover and restorer products.

    2. 2Finding the cause

      Not stated

    3. 3Correction

      This service bulletin includes information on Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability.

    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2025 and prior GM passenger cars and trucks (including medium duty).
    • Condition：The document covers interior cleaning of the instrument panel, hard or plastic surfaces, seats, carpet, leather and vinyl, and the availability of cleaner, stain remover and restorer products.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This service bulletin includes information on Interior Cleaning - Instrument Panel (IP), Hard or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability.

Showing 26 of the 257 you can open. Narrow the search to see the rest.

11 owner complaints have no classified sentences yet, so their causes and repairs are not picked out. Their text is in the list of records.