Skip to content
FaultCrate
日本語Open preview: everything readable

This is an open preview: every record can be read without an account. The details of the plans are in preparation.

GMC Yukon XL 2000–2006

GMC Yukon XLModel years 2000–2006

Change vehicle →
Clear the search
1 conditions added

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:Gauge or instrument faultWarning lightCorrosion or rustNoiseLeakReduced brakingStalls or shuts offLoss of engine power, no acceleration

Record by record

35 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

Work done

How it is said to have ended

  • result not stated5

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (34)

Known issuesRemote keyless entry and front passenger door window, lock, mirror inoperative (reprogram the Passenger Door Module)1

  1. Manufacturer communication2003 GMC FULL-SIZE PICKUPS AND UTILITIES (YUKON XL) ・ 2003-07-01

    RKE fob and front passenger door window, lock, mirror and heated seat inoperative: refresh and reprogram the Passenger Door Module

    1. 1Fault

    2. 2Finding the cause

      Possible causes

      • The Door Lock and Side Window Switch contains a microprocessor called the Passenger Door Module (PDM); the condition and the repair procedure involve the PDM.

      Steps to confirm (in the document’s order)

      1. Vehicles built before 01/03: refer to Bulletin 03-08-52-001C.
      2. Vehicles built during 01/03: refer to Customer Satisfaction Bulletin 03-011.
      3. Vehicles built 02/03 or later: refer to the published Service Information for the symptom the customer experiences.

    3. 3Correction

      Repair

      • Instead of replacing the Door Lock and Side Window Switch, the PDM can now be refreshed and reprogrammed with the Tech 2.

      Caution

      • The Tech 2 must contain software 23.001 (CD 3) or newer; if it does not, download this software before proceeding.
      • Once the correct bulletin is identified, its procedures must be performed in the order given, without skipping any steps.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2003 Chevrolet and GMC full-size pickups and utilities, Cadillac Escalade models and Hummer H2: the RKE key fob does not function and the front passenger door power window, lock, mirror and heated seat are inoperative.
    • Cause：The Door Lock and Side Window Switch contains a microprocessor called the Passenger Door Module (PDM); the condition and the repair procedure involve the PDM.
    • Confirm：Vehicles built before 01/03: refer to Bulletin 03-08-52-001C.
    • Confirm：Vehicles built during 01/03: refer to Customer Satisfaction Bulletin 03-011.
    • Confirm：Vehicles built 02/03 or later: refer to the published Service Information for the symptom the customer experiences.
    • Repair：Instead of replacing the Door Lock and Side Window Switch, the PDM can now be refreshed and reprogrammed with the Tech 2.
    • Caution：The Tech 2 must contain software 23.001 (CD 3) or newer; if it does not, download this software before proceeding.
    • Caution：Once the correct bulletin is identified, its procedures must be performed in the order given, without skipping any steps.

    Open this issue of GM TechLink ↗ The points above are read from an article of TechLink, GM’s monthly publication for dealership technicians. The article itself is not reproduced here.

    Remedy
    Reprogramming Passenger Door Module Owners of some 2003 Chevrolet and GMC full-size pickups and utilities, Cadillac Escalade models and Hummer H2 may have concerns that the RKE key fob does not function, the front passenger door power window, lock, mirror and heated seat are inoperative. The Door Lock and Side Window Switch contains a microprocessor called the Passenger Door Module (PDM). The condition and repair procedure involve the PDM. - Those built before 01/03 -- refer to Bulletin 03-08-52-001C. - Those built during 01/03 -- refer to Customer Satisfaction Bulletin 03-011. - Those built 02/03 or later -- refer to published Service Information for the symptom experienced by the customer. Instead of replacing the Door Lock and Side Window Switch, you can now refresh and reprogram the PDM using your Tech 2. TIP: Your Tech 2 must contain software 23.001 (CD 3) or newer, released March 8. If it does not, you must download this software before proceeding. And once you have identified the correct bulletin, you MUST perform the procedures described in it, in the order given, and do not skip any steps.

STRUCTURE15

  1. Owner complaint2006 GMC YUKON XL 1500 ・ 2014-01-18

    Rear window release button stuck, will not open window

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      WHILE I HAD THE REAR HATCH APART I WAS GOING TO PUT IN A MECHANISM TO ALLOW OPENING THE REAR HATCH FROM INSIDE.

    Read the sentences of the record
    Fault
    THE REAR WINDOW RELEASE BUTTON IS PUSHED ALL THE WAY IN AND WILL NOT OPEN THE WINDOW.
    Remedy
    WHILE I HAD THE REAR HATCH APART I WAS GOING TO PUT IN A MECHANISM TO ALLOW OPENING THE REAR HATCH FROM INSIDE.

  2. Owner complaint2001 GMC YUKON XL 1500 ・ 2011-08-03

    Rear glass hinge broken, glass does not close properly

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    WHEN I PUSHED DOWN TO CLOSE THE REAR GLASS, I NOTICED THAT THE GLASS DID NOT FIT TO CLOSE PROPERLY.
    Cause
    USING A PLASTIC HINGE AT A POINT UNDER HEAVY LOAD SEEMS LIKE AN OBVIOUS DESIGN FLAW. *KB

  3. Owner complaint2003 GMC YUKON XL 1500 ・ 2008-08-30

    Rear hinge on left glass separated from glass

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      FORTUNATELY I NOTICED AND HAD IT REPAIRED (REPLACED) BEFORE AN ACCIDENT OCCURRED. *TR

    Read the sentences of the record
    Fault
    THE REAR HINGE ON THE LFT GLASS CAME AWAY FROM THE GLASS, LEAVING THE REAR WINDOW UNSAFE.
    Remedy
    FORTUNATELY I NOTICED AND HAD IT REPAIRED (REPLACED) BEFORE AN ACCIDENT OCCURRED. *TR

  4. Owner complaint2003 GMC YUKON XL DENALI ・ 2006-08-25

    Rear window hinge disconnected from window

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE WINDOW HINGE ON THE REAR WINDOW OF MY 2003 GMC YUKON BECAME DISCONNECTED FROM THE WINDOW.
    Cause
    IT SEEMS LIKE A MANUFACTURER DEFECT, OR DESIGN FLAW...NOT SOMETHING THAT FAILED BECAUSE OF NORMAL WEAR AND TEAR.

  5. Owner complaint2001 GMC YUKON XL ・ 2005-09-09

    Rear liftgate glass hinges separated from glass due to adhesive failure

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE REAR LIFTGATE HINGES, THAT ARE GLUED TO THE REAR LIFTGATE GLASS, HAS COME FREE FROM THE GLASS.
    Cause
    NEITHER THE GLASS LIFTGATE OR HINGES ARE DAMAGED, THE ATTACHING COMPOUND (I.E. GLUE?) HAS FAILED.

  6. Manufacturer communication2003–2005 GMC YUKON XL ・ 2004-11-04

    Liftgate Relay Location

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      LOCATION OF THE LIFTGATE RELAY. *TC

    Read the sentences of the record
    Remedy
    LOCATION OF THE LIFTGATE RELAY. *TC

  7. Owner complaint2001 GMC YUKON XL ・ 2003-08-17

    Rear tailgate hinged window hinge delamination on 2001 Yukon XL

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE PASSENGER SIDE WINDOW HINGE HAS DELAMINATED FROM THE TAILGATE GLASS RESULTING IN THE WINDOW BEING SECURED TO THE VEHICLE WITH ONE HINGE.
    Cause
    I BELIEVE THAT OPENING THE DOOR WINDOWS ON THE VEHICLE WOULD CAUSE ADDITIONAL STRESS ON THE REMAINING HINGE.

  8. Owner complaint2000 GMC YUKON XL ・ 2003-02-09

    Gaps in rear seals on liftgate

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE GAPS ARE AT THE BOTTOM CORNERS OF THE LIFT GATE (RIGHT AND LEFT SIDES) AND ARE APPROXIMATELY 1 TO 3 INCHES (= 25.4–76.2 mm) LONG AND ABOUT 1/16" WIDE.
    Cause
    THE SEALS APPEAR TO BE INADEQUATE, I.E. INSUFFICIENT IN SIZE OR THICKNESS TO ADEQUATELY SEAL THE BOTTOM CORNERS OF THE LIFT GATE.
    Inspection
    THIS PROBLEM WAS FOUND BY INSPECTION BY MYSELF, AS I WAS INSPECTING THE VEHICLE PRIOR TO ALLOWING THE WARRANTY TO EXPIRE.

  9. Owner complaint2001 GMC YUKON XL 1500 ・ 2011-06-27

    Right rear window hinge broke off

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE RIGHT REAR WINDOW HINGE HOLDING THE REAR WINDOW HATCH BROKE OFF. *TR

  10. Owner complaint2001 GMC YUKON XL 1500 ・ 2010-09-22

    Rear glass hinge separated from window

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    REAR GLASS HINGE SEPARATED FROM WINDOW IN 2001 GMC YUKON XL. *TR

  11. Owner complaint2002 GMC YUKON XL ・ 2010-09-19

    Rear tailgate glass hinge failure and improper closure

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    REAR GLASS DOES NOT CLOSE PROPERLY AND IS AT RISK TO DETACH FROM VEHICLE.

  12. Owner complaint2002 GMC YUKON XL 1500 ・ 2008-11-17

    Liftgate glass detached while driving on highway

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

  13. Owner complaint2001 GMC YUKON XL 1500 ・ 2007-05-25

    Tailgate lift assist pistons failed

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

  14. Owner complaint2003 GMC YUKON XL 1500 ・ 2006-12-28

    Rear window hinge pulling away from glass and window position shifted on liftgate

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE HINGE HOLDING THE REAR WINDOW TO THE LIFTGATE IS PULLING AWAY FROM THE GLASS. (1 more)

  15. Owner complaint2001 GMC YUKON XL ・ 2003-09-24

    Rear tailgate glass hinge broken from bracket

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE PASSENGER SIDE HINGE MOUNTED TO FIBER MATERIAL ADHERED TO GLASS HAS COMPLETLY BROKEN FREE OF GLASS MOUNTING BRACKET.

VISIBILITY4

  1. Manufacturer communication2001–2006 GMC YUKON XL ・ 2017-12-22

    Rear Window Defroster Contact or Tabs Service Information

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Repair

      1. On 2007-2014 Tahoe, Suburban, Yukon and Escalade with moveable glass always replace the defroster tab (GM P/N 25916031) and the power connector (P/N 12034110); on all other vehicles reconnect the original defroster tab.
      2. Remove the rear defroster power connector and crimp a new one to the feed wire; the proper connector, P/N 12034110, is in the Packard Electrical Assortment, Tray 18, Position 5.
      3. Prepare the surface of the used defroster tab and the defroster buss bar with fine grain (500 grit) sandpaper or Emery cloth.
      4. Wipe the prepared contact area with Kent Automotive Acrysol (or equivalent) to remove residual oil or dirt.
      5. Heat the new connector on the buss bar surface to be soldered, holding the connector and defroster tab in place with long nose pliers.

      Part numbers printed in the document

      The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

      Parts

      • Silver solder: Radio Shack (The Source in Canada) 64-013, 0.022" diameter.
      • Solvent: P20005 Kent Automotive Acrysol Solvent (32 fl oz) 946 ml.

      Caution

      • Let the glass warm to the temperature inside the building; soldering creates a hot spot in the glass, so do not solder on cold glass.
      • Heating the glass excessively, or repeatedly without time to cool, may break the glass.
      • A silver-bearing solder must be used; do not attempt the repair with conventional tin/lead alloy solders.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Covers 2000-2015 GM passenger cars and trucks, excluding the 2015 Chevrolet Tahoe, Suburban, GMC Yukon and Cadillac Escalade.
    • Applies to：Vehicles must have the electric rear window defroster (RPO C49).
    • Repair：On 2007-2014 Tahoe, Suburban, Yukon and Escalade with moveable glass always replace the defroster tab (GM P/N 25916031) and the power connector (P/N 12034110); on all other vehicles reconnect the original defroster tab.
    • Caution：Let the glass warm to the temperature inside the building; soldering creates a hot spot in the glass, so do not solder on cold glass.
    • Caution：Heating the glass excessively, or repeatedly without time to cool, may break the glass.
    • Caution：A silver-bearing solder must be used; do not attempt the repair with conventional tin/lead alloy solders.
    • Repair：Remove the rear defroster power connector and crimp a new one to the feed wire; the proper connector, P/N 12034110, is in the Packard Electrical Assortment, Tray 18, Position 5.
    • Repair：Prepare the surface of the used defroster tab and the defroster buss bar with fine grain (500 grit) sandpaper or Emery cloth.
    • Repair：Wipe the prepared contact area with Kent Automotive Acrysol (or equivalent) to remove residual oil or dirt.
    • Repair：Heat the new connector on the buss bar surface to be soldered, holding the connector and defroster tab in place with long nose pliers.
    • Parts：Silver solder: Radio Shack (The Source in Canada) 64-013, 0.022" diameter.
    • Parts：Solvent: P20005 Kent Automotive Acrysol Solvent (32 fl oz) 946 ml.

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This informational bulletin provide information for the technicians to repair the rear window defroster contact or tabs.

  2. Owner complaint2004 GMC YUKON XL ・ 2005-09-03

    Rear window exploded outward on August 15, 2005

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    LEAVING THEIR HOUSE HE PULLED OUT ONTO THE ROAD AT APPROXIMATELY 5 MILES PER HOUR (= 8.05 km/h) AND THE REAR WINDOW EXPLODED OUTWARD AS IF BLOWN OUT FROM THE INSIDE.
    Inspection
    THE PROFESSIONAL WHO REPLACED OUR WINDOW SAID THAT IT APPEARED TO BLOW OUT FROM THE INSIDE.
    Consequence
    LUCKILY OUR CHILDREN AND GRANDCHILDREN SITTING IN THE BACK WERE NOT HURT.*JB

  3. Owner complaint2003 GMC YUKON XL DENALI ・ 2010-10-11

    Rear liftgate glass hinge failure on 2003 GMC Yukon

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

  4. Owner complaint2003 GMC YUKON XL 1500 ・ 2009-06-26

    Rear window fell off and shattered while driving at approximately 30 MPH

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    2003 YUKON XL- REAR WINDOW FELL OFF AN SHATTERED WHILE DRIVING THOUGH CITY TRAFFIC AT APPROXIMATELY 30MPH (= 48.3 km/h). *TR

LATCHES/LOCKS/LINKAGES3

  1. Owner complaint2001 GMC YUKON XL ・ 2007-12-27

    Liftgate hinge failed and liftgate fell off while driving

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    RIGHT GLASS LIFT GATE HINGE FAILED AND BROKE AWAY FROM GLASS AFTER APPROXIMATELY 50,000 MILES (= 80,467 km). (1 more)
    Remedy
    INSTALLATION WAS PERFORMED BY MYSELF. *TR

  2. Manufacturer communication2005–2006 GMC YUKON XL 2500 ・ 2004-12-15

    Unable to Disable Auto Door Locks - Full Size Trucks and Utilities

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      UNABLE TO DISABLE AUTO DOOR LOCKS. THIS INCLUDES 05 CHEVROLET GMC CADILLAC FULL SIZE TRUCKS AND UTILITIES. *EH ALSO INCLUDES AVALANCE, SILVERADO SUBURBAN TAHOE; GMC SIERRA, YUKON, DENALI, YUKON XL, DENALI XL. UPDATED 8/26/08. *PE UPDATED 5/9/11. *PE

    Read the sentences of the record
    Remedy
    UNABLE TO DISABLE AUTO DOOR LOCKS. THIS INCLUDES 05 CHEVROLET GMC CADILLAC FULL SIZE TRUCKS AND UTILITIES. *EH ALSO INCLUDES AVALANCE, SILVERADO SUBURBAN TAHOE; GMC SIERRA, YUKON, DENALI, YUKON XL, DENALI XL. UPDATED 8/26/08. *PE UPDATED 5/9/11. *PE

  3. Owner complaint2004 GMC YUKON XL ・ 2010-04-07

    Multiple concerns: steering noise and locking, brake pedal to floor, AC odor, interior odor, trim panel dropped, keyless entry inoperative

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    A)THE SQUEAKING, CLUNKING, LOCKING STEERING, WHEN TURNING: SERVICE BULLETIN NUMBER: 01863. (5 more)

VISIBILITY/WIPER3

  1. Owner complaint2001 GMC YUKON XL 1500 ・ 2015-09-18

    Rear liftgate window detached when opening

    1. 1Fault

    2. 2Finding the cause

    3. 3CorrectionNot repaired

      THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED.

    Read the sentences of the record
    Fault
    WHILE ATTEMPTING TO OPEN THE REAR LIFTGATE WINDOW, THE WINDOW DETACHED FROM THE VEHICLE.
    Remedy
    THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED.

  2. Owner complaint2001 GMC YUKON XL 1500 ・ 2016-02-29

    Rear liftgate glass separated from hinge during opening

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    WHILE OPENING MY REAR LIFTGATE GLASS THE GLASS SEPARATED FROM THE HINGE HOLDING IT IN PLACE.

  3. Owner complaint2003 GMC YUKON XL ・ 2012-09-21

    Rear window detached while traveling at 30 MPH

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    THE CONTACT STATED THAT WHILE TRAVELING 30 MPH (= 48.3 km/h), THE REAR WINDOW DETACHED FROM THE VEHICLE ABNORMALLY.

No component category2

  1. Manufacturer communication2003 GMC FULL SIZE PICKUP OR UTILITY (YUKON XL) ・ 2002-11-01

    Replacing the door lock and side window switch module without damaging the trim panel

    1. 1Fault

    2. 2Finding the cause

      Not stated

    3. 3Correction

      Repair

      • This is covered in SI documents 849812 and 849813.

      Caution

      • To avoid damaging the trim panel, a screw that retains the switch module to the trim panel must be removed.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Use care when replacing a door lock and side window switch module on a 2003 Chevrolet and GMC full size pickup or utility.
    • Caution：To avoid damaging the trim panel, a screw that retains the switch module to the trim panel must be removed.
    • Repair：This is covered in SI documents 849812 and 849813.

    Open this issue of GM TechLink ↗ The points above are read from an article of TechLink, GM’s monthly publication for dealership technicians. The article itself is not reproduced here.

    Remedy
    Door Switch Module Service Use care when replacing a door lock and side window switch module on 2003 Chevrolet and GMC full size pickup or utility. To avoid damaging the trim panel, it’s necessary to remove a screw that retains the switch module to the trim panel. This is covered in SI documents 849812 and 849813.

  2. Manufacturer communication2003 GMC YUKON XL ・ 2002-10-01

    Automatic door lock programming: the owner's manual procedure is wrong

    1. 1Fault

    2. 2Finding the cause

      Steps to confirm (in the document’s order)

      • When cycling through the lock and unlock modes with the door switches, count the chimes after each press to determine each lock option.

    3. 3Correction

      Repair

      • The corrected procedure is in SI under document number 866362 and can be given to customers.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：On 2003 Tahoe, Suburban, Silverado, Yukon, Yukon XL and Sierra, customers may have difficulty programming the automatic door locks by the procedure in Section 2 of the owner's manual.
    • Repair：The corrected procedure is in SI under document number 866362 and can be given to customers.
    • Confirm：When cycling through the lock and unlock modes with the door switches, count the chimes after each press to determine each lock option.

    Open this issue of GM TechLink ↗ The points above are read from an article of TechLink, GM’s monthly publication for dealership technicians. The article itself is not reproduced here.

    Remedy
    Power Door Lock Programming On 2003 Chevrolet Tahoe, Suburban, Silverado C/K Pickup, and GMC Yukon, Yukon XL, or Sierra C/K Pickup, customers may have difficulty in programming the automatic door locks, following the procedure in Section 2 of the owner's manual. The corrected procedure is located in SI under document number 866362 and can be made available to your customers. When cycling through the lock and unlock modes by using the lock and unlock switches on the door, count the number of chimes heard after each press of the switch to determine each lock option.

STEERING2

  1. Owner complaint2004 GMC YUKON XL ・ 2010-04-01

    Multiple concerns: steering noise and locking, brake pedal, air conditioning, and more

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    A) THE SQUEAKING, CLUNKING, LOCKING STEERING, WHEN TURNING: SERVICE BULLETIN NUMBER: 01863; NHTSA ITEM NUMBER: 10006616.. (7 more)

  2. Owner complaint2004 GMC YUKON XL ・ 2010-03-08

    Multiple concerns since purchase including brake, air conditioning, and electrical issues

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    B) THE BRAKES, WHEN STOPPED, AT TIMES, PRESSES COMPLETELY TO THE FLOOR. (6 more)

ENGINE AND ENGINE COOLING1

  1. Owner complaint2004 GMC YUKON XL ・ 2010-04-24

    Multiple concerns since purchase including steering and other issues

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

    Read the sentences of the record
    Fault
    SINCE FIRST PURCHASE, THE EVER PRESENT CONCERNS, INHERENT WITH OUR GENERAL MOTORS GMC YUKON XL, HAVE GROWN; TO WHEREBY, THEY ARE SAFETY, SECURITY, AND WELL-BEING CONCERNS: A) THE SQUEAKING, CLUNKING, LOCKING STEERING, WHEN TURNING: SERVICE BULLETIN NUMBER: 01863. (7 more)

EQUIPMENT1

  1. Manufacturer communication2000–2005 GMC YUKON XL DENALI ・ 2018-05-21(1 earlier editions of this document folded here)

    Liftgate Applique Replacement Procedure

    1. 1Fault

      • Condition 1: a dimpling or deformation is seen near an outer edge of the liftgate center applique.
      • Condition 2: paint damage on the liftgate at the lower outboard edges of the center applique.

    2. 2Finding the cause

      Possible causes

      • The applique design might allow deformation or dimpling of its surface if the retaining nuts are overtightened.
      • The applique design together with the forming of the license plate pocket in the liftgate may let the lower outboard edges of the applique contact the liftgate.

    3. 3Correction

      Repair

      1. For 2011 or earlier vehicles, replace the liftgate center applique with the appropriate new service part from the table.
      2. To create clearance, add GM washer P/N 15911310 to the applique between the foam washer and the mounting boss at each of the four mounting stud locations.

      Part numbers printed in the document

      The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

      Parts

      • P/N 15911310 is a 0.25 mm thick Mylar washer.
      • Applique 22777530 is for GMC non-hybrid without rear vision camera (-UVC).
      • Applique 22777531 is for GMC non-hybrid with rear vision camera (&UVC).

      Part numbers printed in the document

      The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

      Caution

      • The updated applique design went into production for the 2012 model year; the applique should not need replacement on a 2012 or newer vehicle unless Condition 1 is present.
    Read the sentences of the record

    From the manufacturer’s document

    • Applies to：Applies to 2007-2013 GMC Yukon models and Yukon XL models (note: earlier Yukon model years are not listed).
    • Condition：Condition 1: a dimpling or deformation is seen near an outer edge of the liftgate center applique.
    • Cause：The applique design might allow deformation or dimpling of its surface if the retaining nuts are overtightened.
    • Condition：Condition 2: paint damage on the liftgate at the lower outboard edges of the center applique.
    • Cause：The applique design together with the forming of the license plate pocket in the liftgate may let the lower outboard edges of the applique contact the liftgate.
    • Repair：For 2011 or earlier vehicles, replace the liftgate center applique with the appropriate new service part from the table.
    • Caution：The updated applique design went into production for the 2012 model year; the applique should not need replacement on a 2012 or newer vehicle unless Condition 1 is present.
    • Repair：To create clearance, add GM washer P/N 15911310 to the applique between the foam washer and the mounting boss at each of the four mounting stud locations.
    • Parts：P/N 15911310 is a 0.25 mm thick Mylar washer.
    • Parts：Applique 22777530 is for GMC non-hybrid without rear vision camera (-UVC).
    • Parts：Applique 22777531 is for GMC non-hybrid with rear vision camera (&UVC).

    Open the manufacturer’s document (PDF) ↗ The points above were read from this document.

    Remedy
    This preliminary information bulletin provides a procedure for replacement of the liftgate applique for concerns regarding the applique being deformed or dimpled or paint damage at the lower edge of the applique

SIDE/REAR1

  1. Manufacturer communication2000–2001 GMC YUKON XL ・ 2001-11-19

    Concerns with Scratches on the Rear Window Lift Glass Caused by the Rear Wiper

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      CONCERNS WITH SCRATCHES ON THE REAR WINDOW LIFT GLASS CAUSED BY THE REAR WIPER. *TT

    Read the sentences of the record
    Remedy
    CONCERNS WITH SCRATCHES ON THE REAR WINDOW LIFT GLASS CAUSED BY THE REAR WIPER. *TT

UNKNOWN OR OTHER1

  1. Owner complaint2003 GMC YUKON XL 1500 ・ 2008-08-12

    2003 Yukon XL rear glass hinge failure while driving

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      Not stated

    Read the sentences of the record
    Fault
    2003 YUKON XL REAR GLASS HINGE (DRIVER'S SIDE) FAILED WHILE DRIVING. (1 more)

Showing 34 of the 35 you can open. Narrow the search to see the rest.

2 owner complaints have no classified sentences yet, so their causes and repairs are not picked out. Their text is in the list of records.