Skip to content
FaultCrate
日本語Open preview: everything readable

This is an open preview: every record can be read without an account. The details of the plans are in preparation.

GMC Yukon XL 2000–2006

GMC Yukon XLModel years 2000–2006

Change vehicle →
Clear the search
1 conditions added

Common on this vehicle:Warning lightNoiseParking brakeReduced brakingCorrosion or rustLeakOverheatingSmoke or fire

causeElectronic Brake Control ModuleRemove

Possible causes

Warning light8 records
Brakes
Transmission and driveline
Electrical, wiring and power
Engine
Exhaust and emissions
Fuel system
1Parking brake linings worn out prematurely, parking brake does not hold (PBR single-shoe drum-in-hat)1500 only0Brake pipe (brake line) corrosion and rupture0ABS light with C0265/C0201/U1041 or no communication with brake module (EBCM ground G110)0Front right-hand brake pipe contact with body cross sill - recall 00V-3450Service Brake Booster message on a Hydroboost vehicle with DTC C0136 (instrument cluster not SPS programmed)0Transfer case service light, New Venture Gear transfer case (replace the encoder motor sensor and reprogram the TCCM)0Intermittent battery lamp with history DTC B1489 after BGCM replacement (module not SPS programmed)0Intermittent MIL, service lamps/messages or DTCs from connector fretting corrosion0Reduced Engine Power from throttle body connector crimp, broken wire or grounds0Crankshaft position sensor may work intermittently or fail (8.1L V8) - recall 07V-5218.1L only0Intake manifold gasket leak (cold idle misfire, lean codes)0Single-cylinder misfire (P0300-P0308) and/or chirp, squeak or tick at camshaft speed: worn cam lobe / lifter, valve or valve spring0P0300 after engine repairs: injector connectors crossed (cylinders 5-7 / 6-8)0Rear bank knock sensor corrosion from water intrusion (P0332)4.8L, 5.3L, 6.0L only0P0420 / P0430 on a new or just-replaced catalytic converter (break-in not completed)0Fuel module reservoir assembly: fuel pump wire connectors may overheat - recall 05V-1551500 only0DTC P0446 set with the SES lamp on (replace the EVAP vent solenoid, not the canister)
7 causes not drawn
Causes with no correction stated (4)

Causes the records name for which no check or repair is stated, in a technical document or in a record. Press one for the records that name it.

Brakes
Electronic Brake Control Module: failed (8)Service Stability message with DTC C0131, C0196, C0290 and/or C0292 (0)
Engine
Throttle Body: failed (1)
Electrical, wiring and power
Intermittent no start with Service Stability, ABS light, 'Unknown Driver' and multiple DTCs / no module communication (0)

The documents say what to doOnly records name itThe size of a node, the width of a link and the numbers are records matching this search, not likelihoods.

FaultCrate・GMC Yukon XL 2000–2006・Warning light

Candidate cause (the documents say what to do)

Parking brake linings worn out prematurely, parking brake does not hold (PBR single-shoe drum-in-hat)

Applies to: 1500 only

ODI is aware of over 600 complaints of premature parking brake wear-out in all MY 1999-2002 C/K 1500 trucks, regardless of transmission type; most involved vehicles with 20,000-60,000 miles (= 32,187–96,561 km), or 15-41 months in service.

Most complaints (over 90%) concerned a worn out or inoperative parking brake system, usually discovered during a service visit or mandatory state safety inspection.

What to do

  1. On complaint vehicles examined in the field, wear occurred earlier and to a greater extent on the driver's side parking brake unit and was largely localized at the tip of one of the linings.
  2. Bulletin 01-05-26-001 "Park Brake - Low Effort Apply System Description" (Mar 2001) describes a park brake test procedure.
  3. A revised clip designed to exert less force on the shoe went into MY 2003 production and into the service part stream. Installing the newer clip and replacing worn linings has been shown to remedy the defect.
  4. The closing report lists a bulletin of Aug 2004 as 02-05-26-001B "Brakes - Parking Brake Shoe Retainer Clip Availability", announcing a new retainer clip service kit for DIH-equipped vehicles.
  5. In the recall, dealers install a low-force spring clip retainer on vehicles with the PBR parking brake system and a redesigned parking brake cable assembly on vehicles with the TRW parking brake system.
  6. That bulletin releases a rear parking brake retaining spring clip kit for service: two parking brake hold down spring clips and bolts.
Read the remaining 3 steps

Caution: The vehicles warn the operator with a chime if driven over 3 mph (= 4.83 km/h) with the parking brake engaged.

What is needed

Parts and materials
  • Revised clip (designed to exert less force on the shoe)
  • Parking brake shoe kit
  • Rear parking brake retaining spring clip kit (when the clips need replacing but the parking brake shoes do not)
  • Parking brake retainer spring clip kit 88982879 (for C/K, M/L and G models)

Part numbers printed in the document

The numbers are as the document prints them. The name and the replacing number are what the pages of GMPartsGiant, a reseller of genuine parts and not GM, state. Aftermarket equivalents are not checked here (the links only search by number). Confirm the fit for the vehicle (VIN) before ordering.

Labor time
Not stated
Special tools
  • J 46277 Rotor Removal Tool (to remove the rotor)
  • J 6125-B Slide Hammer (used with J 46277)
Scan tool
Not stated

Only what the technical documents state. "Not stated" does not mean not needed.

In the records

No record states work done for this cause.

See the evidence (1 technical documents, 1 records)

Passages of the technical documents

  • ODI collected data on the manual-transmission Silverado/Sierra 1500 pickups (the subject vehicles) and on peer vehicles, including all MY 1999-2004 automatic-transmission GM C/K pickups and sport-utility vehicles based on the same platform.

    During the investigation, ODI collected data concerning the manual transmission-equipped Silverado/Sierra 1500 pickups (subject vehicles) and millions of peer vehicles that included ½ ton pickup trucks manufactured by Ford and Dodge, as well as all MY 1999 - 2004 automatic transmission-equipped GM C/K pickups and sport-utility vehicles based on the same platform as that used in the subject vehicles.

    NHTSA ODI 2005-05-10

  • The subject brake system is used in over 4 million MY 1999 - 2004 C/K 1500 vehicles; field data and manufacturing changes indicate that the defect is present only in the MY 1999 - 2002 vehicles.

    The subject brake system is used in over 4 million MY 1999 - 2004 C/K 1500 vehicles. Field data and manufacturing changes indicate that the defect is present only in the MY 1999 - 2002 vehicles.

    NHTSA ODI 2005-05-10

  • Bulletin 02-05-26-002 "Brakes - Scraping Noises from Rear of Vehicle" (Oct 2002) announced the low-force clip for certain ½ ton GMT800s; 02-05-26-002A (Feb 2003) added Suburban and Yukon XL.

    Oct-2002 02-05-26-002 "Brakes- Scraping Noises from Rear of Vehicle" Announced the availability of the low-force clip in certain ½ ton GMT800s Feb-2003 02-05-26-002A "Brakes- Scraping Noises from Rear of Vehicle" Adds Suburban and Yukon XL to earlier models

    NHTSA ODI 2005-05-10

  • ODI is aware of over 600 complaints of premature parking brake wear-out in all MY 1999-2002 C/K 1500 trucks, regardless of transmission type; most involved vehicles with 20,000-60,000 miles (= 32,187–96,561 km), or 15-41 months in service.

    To date, ODI is aware of over 600 nonduplicative consumer complaints³ reporting premature parking brake wear-out in all MY 1999-2002 C/K 1500 trucks, regardless of transmission type. The majority of complaints involved vehicles that had accumulated 20,000 - 60,000 miles, or 15 - 41 months in service.

    NHTSA ODI 2005-05-10

Read every statement and its source →

A cause or a result a complaint states is the owner’s view or what a dealer told them, not an established fact.

Put together by FaultCrate from public records and technical documents. The cause and the repair are for the workshop to decide with the vehicle in front of it. Counts are records, not failure rates.