Skip to content
FaultCrate
日本語Open preview: everything readable

This is an open preview: every record can be read without an account. The details of the plans are in preparation.

GMC Yukon 2000–2006

GMC YukonModel years 2000–2006

Change vehicle →
Clear the search
1 conditions added

Common on this vehicle:Reduced brakingCorrosion or rustWarning light

issueBrake pipe (brake line) corrosion and ruptureRemove

Record by record

1 records state a cause or a remedy. Each record is shown as short labels in the order fault → finding the cause → correction. Press a label to narrow to the records that state it.

Symptom

Component named as the cause

A ribbon is as wide as the records that state both of its ends (only the commonest are drawn). A record that names several symptoms or components runs through each. Orange is records that say the fault came back or was not fixed. Results come from owners’ reports only; one that does not say is “result not stated”. None of this is a likelihood of a cause or a rate at which work succeeds.

Read the records one by one (1)

Known issuesBrake pipe (brake line) corrosion and rupture1

  1. Owner complaint2003 GMC YUKON ・ 2016-08-23

    Total brake failure when braking at intersection; ABS light on

    1. 1Fault

    2. 2Finding the cause

    3. 3Correction

      IN ORDER TO IMPROVE VEHICLE SAFETY THE LINES WILL ALL BE REPLACED WITH STAINLESS STEEL SO THIS DOESN'T HAPPEN AGAIN.

      What the documents say to do

      Brake pipe (brake line) corrosion and rupture

      Confirm

      • In the joint inspections, scaling or flaking corrosion was taken as indicating the onset of metal loss and given the second lowest ranking (2); a leaking or previously repaired pipe was the lowest (1).

      Repair

      1. GM recommends replacing the entire set of pipes whenever any pipe leaks or is corroded enough to need replacement.
      2. On June 28, 2013 GM released 66 new part numbers for servicing brake pipes in 1999-2007 GMT800 pickups and utility vehicles.

      Caution

      • Analysis of repair records indicates that consumers often elect to repair only the failed circuit.
    Read the sentences of the record
    Fault
    WHILE APPROACHING AN INTERSECTION I APPLIED THE BRAKES THE PEDAL WENT TO THE FLOOR ABS LIGHT CAME ON AND THE WAS TOTAL BRAKE FAILURE.
    Remedy
    IN ORDER TO IMPROVE VEHICLE SAFETY THE LINES WILL ALL BE REPLACED WITH STAINLESS STEEL SO THIS DOESN'T HAPPEN AGAIN.
    Inspection
    THEY FOUND RUSTED BRAKE LINES AT THE ABS VALVE ALONG WITH A RUSTED BACKING PLATE FOR THE VALVE.