Skip to content
FaultCrate
日本語Open preview: everything readable

This is an open preview: every record can be read without an account. The details of the plans are in preparation.

GMC Yukon 2000–2006

GMC YukonModel years 2000–2006

Change vehicle →
Clear the search
2 conditions added

Common on this vehicle:Warning lightHard start or long crankDoes not startNoise

Possible causes

Noise, P03013 records
Engine
Body, doors and interior
Brakes
Transmission and driveline
Electrical, wiring and power
Exhaust and emissions
1Single-cylinder misfire (P0300-P0308) and/or chirp, squeak or tick at camshaft speed: worn cam lobe / lifter, valve or valve spring0Accessory drive belt whine (power steering pump pulley repositioned)0Engine vibration or noise at idle felt in the steering wheel or seat (reprogram the PCM)0Oil pump pickup (screen) O-ring cut: engine tick / lifter noise0Rear bank knock sensor corrosion from water intrusion (P0332)0Rattle from the center of the dash (cowl insulator clip)0Snap or popping noise from the front of the vehicle (slot the front crossmember mounting holes)0Headliner or roof rattle (roof drain channel)0Side access door noise (door check link replacement)0Buzz at the accelerator pedal on the first acceleration after start (Supplemental Brake Assist self-test, normal)0Parking brake linings worn out prematurely, parking brake does not hold (PBR single-shoe drum-in-hat)04L60-E / 4L65-E clunk on 2-3 upshift or 3-2 downshift (normal condition)04L80-E / 4L85-E planetary gear whine in first and second gear0Grind / ratchet noise when shifting into Park in 4LO (characteristic)0Generator whine in the audio system (new ground for radio and amplifier)0Hum or fan noise from the navigation radio (internal cooling fan, normal)0Exhaust pop or ping noise (replace the heat shield, not the exhaust system)
11 causes not drawn

The documents say what to doOnly records name itThe size of a node, the width of a link and the numbers are records matching this search, not likelihoods.

FaultCrate・GMC Yukon 2000–2006・Noise, P0301

Candidate cause (the documents say what to do)

4L80-E / 4L85-E planetary gear whine in first and second gear

The 4L80E/4L85E may have planetary gear whine noise in first and second gear.

The noise is typically louder in first gear than in second.

What to do

  1. Compare the vehicle with an identically built vehicle (same GVWR) before attempting any repairs.
  2. The correct end play is between 0.127-0.508 mm (0.005-0.020 in).
  3. If the noise is judged abnormal and the transmission was built after 9-01-03, perform the Rear Unit End Play Check (SI Document ID # 52027).
  4. If end play is out of specification, inspect and replace the output planetary gear set as necessary.
  5. If end play is within specification, replace the transmission assembly.
  6. Set rear end play between .005" and .020" using the correct selective thrust washer (674); target between .010" and .015".

Caution: This planetary gear whine can be characteristic of the 4L80E/4L85E.

In the records

No record states work done for this cause.

See the evidence (1 technical documents, 0 records)

Passages of the technical documents

  • 1999-2007 GMC Sierra, Yukon XL

    General Motors (published by NHTSA) 2012-12-17

  • with 4L80E (RPO MT1) or 4L85E (RPO MN8)

    General Motors (published by NHTSA) 2012-12-17

  • The 4L80E/4L85E automatic transmission may experience a condition of planetary gear whine noise in first and second gear.

    General Motors (published by NHTSA) 2012-12-17

  • The planetary gear noise is typically louder in first gear as compared to second.

    General Motors (published by NHTSA) 2012-12-17

Read every statement and its source →

Records

None among the records that can be opened now.

See all 0 records of this cause →

A cause or a result a complaint states is the owner’s view or what a dealer told them, not an established fact.

Put together by FaultCrate from public records and technical documents. The cause and the repair are for the workshop to decide with the vehicle in front of it. Counts are records, not failure rates.