Skip to content
FaultCrate
日本語

This is an open preview: every record can be read without an account.

GMC Yukon 2000–2006

GMC YukonModel years 2000–2006

Change vehicle →
Clear the search
2 conditions added

The vehicle (where a record says)

A record is under an engine, a drive or a series only where it says so: the characters of the vehicle identification number filed with a complaint, its text, or what its document says it applies to. A record that does not say is kept as "not stated". The filed numbers and the documents do not tell 4WD from AWD.

Common on this vehicle:LeakWarning lightMisfire or rough idleGauge or instrument faultStalls or shuts offDoes not startHard start or long crankLoss of engine power, no acceleration

Possible causes

Fuel system, 200042 records
Fuel system
Engine
Body, doors and interior
Electrical, wiring and power
Exhaust and emissions
5Fuel Pump: failed, leaking1Aftermarket part (not the vehicle as built): Fram G3727 replacement fuel filter connector - recall 06E-0431Fuel gauge reads low or drops to empty in Park / Neutral (normal characteristic)1Fuel pressure regulator buzz / hum after replacement (check fuel pump feed voltage drop and connector crimps)4.8L, 5.3L, 6.0L only1Fuel Tank: leaking1Cylinder1Cylinder Bore: worn1Engine Block1Rear door window inoperative (motor replacement)1Power Window: failed1Engine Control Module: failed1Purge Solenoid: failed
Causes with no correction stated (3)

Causes the records name for which no check or repair is stated, in a technical document or in a record. Press one for the records that name it.

Fuel system
Fuel Pump Bushing: broken (2)Fuel Tank Filler: leaking (1)
Electrical, wiring and power
Fuse: failed (1)

The documents say what to doOnly records name itThe size of a node, the width of a link and the numbers are records matching this search, not likelihoods.

FaultCrate・GMC Yukon 2000–2006・Fuel system, 2000

Candidate cause (the documents say what to do)

Aftermarket part (not the vehicle as built): Fram G3727 replacement fuel filter connector - recall 06E-043

The connector on the fuel filter was not manufactured to Honeywell's specification.

As a result, the O-ring may not seat correctly on the fuel line.

What to do

  1. The part number (G3727), country of origin (Mexico) and the date code (e.g., X60031) are located on the side of the fuel filter.
  2. Honeywell notifies owners and replaces the fuel filters free of charge.

Caution: The recall pertains only to aftermarket Fram fuel filters and has no relation to original equipment on the listed vehicles.

What is needed

Parts and materials
  • Replacement fuel filter (replaced by Honeywell free of charge)
Labor time
Not stated
Special tools
Not stated
Scan tool
Not stated

Only what the technical documents state. "Not stated" does not mean not needed.

In the records

  • Fuel Filter: replaced 1
See the evidence (2 technical documents, 1 records)

Passages of the technical documents

  • The recall covers Fram replacement fuel filters P/N G3727 with the listed date codes and a Mexico country-of-origin marking, made from October 18, 2005 through March 21, 2006.

    CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES.

    NHTSA 2006-05-19

  • The connector on the fuel filter was not manufactured to Honeywell's specification.

    THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION.

    NHTSA 2006-05-19

  • As a result, the O-ring may not seat correctly on the fuel line.

    AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

    NHTSA 2006-05-19

  • This may cause an inadequate seal at the connection, potentially leading to a fuel leak.

    THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK.

    NHTSA 2006-05-19

Read every statement and its source →

Records

None among the records that can be opened now.

See all 1 records of this cause →

A cause or a result a complaint states is the owner’s view or what a dealer told them, not an established fact.

Put together by FaultCrate from public records and technical documents. The cause and the repair are for the workshop to decide with the vehicle in front of it. Counts are records, not failure rates.